5Venting Systems, Alcove | Hearth and Home Technologies CB1200-B

R

CB 1200 Pellet Stove

5Venting Systems

A. Alcove

A

C

D

B

Figure 12.1

	Alcove Installation	Inches	Millimeters
A	Minimum Alcove Height	44	1117
B	Minimum Alcove Width	40-1/2	1029
C	Maximum Alcove Depth	36	915
D	Minimum Alcove Side Wall	6	152
not shown	Top of Unit to Combustibles	12-1/2	318

All minimums listed are to a combustible surface.

NOTE:

•Illustrations reﬂect typical installations and are FOR DESIGN PURPOSES ONLY.

•Illustrations/diagrams are not drawn to scale.

•Actual installation may vary due to individual design preference.

Page 12

7014-082D

September 1, 2008

Image 12

Hearth and Home Technologies CB1200-B owner manual 5Venting Systems, Alcove

Contents

Classic BAY 1200 Pellet Stove Hot glass will cause burns Testing Lab & Report Number Serial Number Model Mfg Date CB 1200 Pellet StoveBehind left side curtain on outside of hopper wall Table of Contents Listing and Code Approvals Design, Installation & Location Considerations Fire SafetyGetting Started Appliance Location CB 1200 Pellet Stove Tools And Supplies Needed Inspect Appliance & Components and Pre-Use Check List 3Dimensions and Clearances Appliance Dimensions CB 1200 Pellet Stove Clearances to Combustibles UL and ULC Exception for Horizontal Installations CB 1200 Pellet Stove Hearth Pad Requirements UL and ULCHearth Pad Requirements 4Vent Information Pipe Selection Chart CB 1200 Pellet Stove Equivalent Feet of PipeExample of 3 Elbow-Rear Vent Termination Calculaton Example 5Venting Systems Alcove Straight Out DegreeCB 1200 Pellet Stove Through The Wall CB 1200 Pellet Stove Vertical Through The Wall & Vertical Masonry Alternate Masonry 6Mobile Home Rear Installation Floor Installation 7Appliance Set-UpOutside Air Kit Instructions CB 1200 Pellet Stove Top Vent Adapter Installation Rear Vent and Rear Vent to Top Vent Adapter InstallationInstalling the Top Vent Adapter See Figure Installed Clip Installing Logo Nickel Only Charred Areas in the BackTop Log, Left Right CB 1200 Pellet Stove Door Installation Thermostat InstallationTo install door To adjust latches 8Operating Instructions Fuel Size And Material General Operating Information Feed Rate Adjustment Instructions Starting Your First Fire Frequently Asked Questions Button. See .1, page 22 . When you pressCB 1200 Pellet Stove Ignition Cycles Troubleshooting SymptomPossible Cause Corrective Action Page Page Quick Reference Maintenance Chart Cleaning or Inspection10Maintaining & Servicing Your Appliance Frequency Daily Weekly Monthly Yearly Cleaning Firepot with Cleaning Rod & Firepot Scraper Cleaning Ash PanCleaning Heat Exchanger Chambers & Drop Tube Ash Removal from Firebox Cleaning Beneath Heat Exchanger Door Latch Inspection Cleaning Exhaust PathCleaning the Hopper Cleaning the Glass Cleaning Exhaust Blower Requires No Lubrication Cleaning the Top Vent Adapter Preparing Firebox for Non-Burn Season Frequency Yearly CB 1200 Pellet Stove High Ash Fuel Content Maintenance Convection Blower Replacement Exhaust Blower Replacement Remove existing blower Install new blowerRe-install blower to blower housing Glass Replacement Replacing Side Glass Screws Reference Materials Component Function & Location Vacuum Switch Wiring Harness See .1 belowSnap Disc #1 Convection Blower 145F Snap Disc #2 Thermostat Override 200F CB 1200 Pellet Stove Component Locations CB 1200 Pellet Stove Exploded Views Glass Size Center 13-7/8 wide x 11 highGlass Size Sides 8 wide x 11 high Nbr Description CB 1200 Pellet Stove CB 1200 Pellet Stove Service Parts and Accessories Item # Parts Alphabetical Order Item # Service Parts Alphabetical Order Accessories Appliance CB 1200 Pellet Stove Service And Maintenance Log Date of Service Performed By Description of Service CB 1200 Pellet Stove Homeowner’s Notes CB 1200 Pellet Stove Warranty Policy CONDITIONS, Exclusions & Limitation of Liability Hearth & Home Technologies Limited Warranty Cont’d Contact Information