Manuals / Brands / Household Appliance / Stove / Hearth and Home Technologies / Household Appliance / Stove

Hearth and Home Technologies CB1200-B CB 1200 Pellet Stove , B. Clearances to Combustibles (UL and ULC)

1 48

Download 48 pages, 1.46 Mb

Page 8 7014-082D September 1, 2008

R

CB 1200 Pellet Stove

Straight Back Against

Wall

Inches Millimeters

ABack Wall to Appliance 2 51

BSide Wall to Appliance 6 152

Corner Installation Inches Millimeters

CWalls to Appliance 2 51

Vertical Installation Inches Millimeters

DBack Wall to Flue Pipe 3 76

ESide Wall to Top 6 152

FBack Wall to Appliance 7.5 191

Installations with:

3 to 3 inch Top Vent Adapter and

3 to 6 inch Offset Adapter Kit

Corner Installation Inches Millimeters

GWalls to Appliance 2 51

B. Clearances to Combustibles (UL and ULC)

D

E

F

A

B

Fire Risk.

Comply with all minimum clearances to

combustibles as speciﬁed.

WARNING

Failure to comply may cause house ﬁre.

NOTE:

• Illustrations reﬂect typical installations and are FOR

DESIGN PURPOSES ONLY.

• Illustrations/diagrams are not drawn to scale.

• Actual installation may vary due to individual design

preference.

C

C

G

G

Alcove Installation Inches Millimeters

Minimum Alcove Height 44 1117

Minimum Alcove Width 40-1/2 1029

Maximum Alcove Depth 36 915

Minimum Alcove Side Wall 6 152

Top of Unit to Combustibles 12-1/2 318

Contents

Main CLASSIC BAY 1200 PELLET STOVE Owners Manual CB1200-B Installation and Operation Model: SAMPLE and Welcome to the Quadra-Fire Family! ATTENTION: CAUTION: SAMPLE SERIAL NUMBER / SAFETY LABEL LOCATION: Behind left side curtain on outside of hopper wall. TABLE OF CONTENTS Section 1: Listing and Code Approvals Section 2: Getting Started Section 3: Dimensions & Clearances Section 4: Vent Information CB 1200 Pellet Stove 1 C. Glass Specications A. Appliance Certication E. BTU & Efciency Specications CB 1200 Pellet Stove 2 A . Design, Installation & Location Considerations B. Fire Safety CB 1200 Pellet Stove D. Inspect Appliance & Components and Pre-Use Check List C. Tools And Supplies Needed September 1, 2008 7014-082D Page 7 CB 1200 Pellet Stove Figure 7.2 - Top View with Top Vent Adapter 3 A. Appliance Dimensions 28-1/2 in. (724mm) CB 1200 Pellet Stove B. Clearances to Combustibles (UL and ULC) CB 1200 Pellet Stove Must extend 2 inches (51mm) beyond each side of pipe (shaded area) C. Hearth Pad Requirements (UL and ULC) L* K K M Hearth Pad Requirements K L* M CB 1200 Pellet Stove 4 A. Chimney and Exhaust Connection B. Venting Termination Requirements CB 1200 Pellet Stove D. Pipe Selection Chart C. Equivalent Feet of Pipe Example of 3 Elbow-Rear Vent Termination Calculaton 5 A B C D CB 1200 Pellet Stove Straight Out B. Through The Wall 45 Degree CB 1200 Pellet Stove C. Vertical D. Through The Wall & Vertical September 1, 2008 7014-082D Page 15 CB 1200 Pellet Stove Figure 15.2 F. Alternate Masonry E. Masonry 6 in. (152mm) Minimum CB 1200 Pellet Stove 6 You must use a Quadra-Fire Outside Air Kit for installation in a mobile home. A. Mobile Home Installation CB 1200 Pellet Stove 7 A. Outside Air Kit Instructions CB 1200 Pellet Stove 3 to 3 inch Top Vent Adapter 3 to 6 inch Top Vent Offset Adapter B. Top Vent Adapter Installation C. Rear Vent and Rear Vent to Top Vent Adapter Installation CB 1200 Pellet Stove D. Optional Brick Set Installation E. Brick Clip Installation CB 1200 Pellet Stove G. Optional Gold or Nickel Grille Assembly Install Logo F. Optional Log Set Placement Instructions LOCATING PINS Charred Areas in the Back H. Installing Logo (Nickel Only) CB 1200 Pellet Stove J. Thermostat Installation Hinge I. Door Installation Hinge Pin CB 1200 Pellet Stove 8 A. Fuel Size And Material B. General Operating Information WARNING CB 1200 Pellet Stove E. Fire Characteristics C. Before Your First Fire F. Feed Rate Adjustment Instructions D. Starting Your First Fire CB 1200 Pellet Stove G. Ignition Cycles H. Frequently Asked Questions ISSUES SOLUTIONS Back side of Firepot Firepot floor left open CB 1200 Pellet Stove 9 Symptom CB 1200 Pellet Stove Symptom Possible Cause Corrective Action CB 1200 Pellet Stove Symptoms Possible Cause Corrective Action CB 1200 Pellet Stove 10 B. Quick Reference Maintenance Chart C. General Maintenance A. Proper Shutdown Procedure Page Page Page CB 1200 Pellet Stove D. High Ash Fuel Content Maintenance E. Blower Replacement F. Bafe Removal H. Glass Replacement NOTE: CB 1200 Pellet Stove 11 A. Component Function & Location When describing the location of a component, it is always AS YOU FACE THE FRONT OF THE APPLIANCE. Page CB 1200 Pellet Stove B. Component Locations Cleaning Rods Heat Exchanger Tubes Page 38 7014-082D September 1, 2008 CB 1200 Pellet Stove Figure 38.1 - Door, Face, Glass & Door Latch Assembly Figure 38.2 - Firepot, Igniter & Thermocouple C. Exploded Views Glass Size Center: 13-7/8 wide x 11 high Glass Size Sides: 5-1/8 wide x 11 high Page Page September 1, 2008 7014-082D Page 41 D. Service Parts and Accessories Item # Parts (Alphabetical Order) Part No. Page 42 7014-082D September 1, 2008 Item # Service Parts (Alphabetical Order) Part No. September 1, 2008 7014-082D Page 43 Appliance Part No. Classic Bay 1200 Freestanding Pellet Stove CB1200-B Accessories Part No. Page Page CB 1200 Pellet Stove G. Warranty Policy Page CONTACT INFORMATION: We recommend that you record the following pertinent information for your CB1200-I PELLET STOVE NOTICE DO NOT DISCARD THIS MANUAL