Hearth and Home Technologies CB1200-B specification

R

CB 1200 Pellet Stove

B. Component Locations

Heat	Fan
Output	Speed
HIGH	HIGH
MED
LOW	LOW
Reset Button	Call Light

Figure 37.1

Power Outlet

Terminal Block.

Center 2 screws for

Thermostat Wires

Figure 37.2

Cleaning Rods

Heat Exchanger Tubes

Figure 37.3

Outside Air

Flex Hose

Convection Blower

Figure 37.4

September 1, 2008

7014-082D

Page 37

Image 37

Hearth and Home Technologies CB1200-B owner manual CB 1200 Pellet Stove Component Locations

Contents

Hot glass will cause burns Classic BAY 1200 Pellet Stove CB 1200 Pellet Stove Testing Lab & Report Number Serial Number Model Mfg DateBehind left side curtain on outside of hopper wall Table of Contents Listing and Code Approvals Fire Safety Design, Installation & Location ConsiderationsGetting Started Appliance Location Inspect Appliance & Components and Pre-Use Check List CB 1200 Pellet Stove Tools And Supplies Needed Appliance Dimensions 3Dimensions and Clearances CB 1200 Pellet Stove Clearances to Combustibles UL and ULC CB 1200 Pellet Stove Hearth Pad Requirements UL and ULC Exception for Horizontal InstallationsHearth Pad Requirements 4Vent Information CB 1200 Pellet Stove Equivalent Feet of Pipe Pipe Selection ChartExample of 3 Elbow-Rear Vent Termination Calculaton Example Alcove 5Venting Systems Degree Straight OutCB 1200 Pellet Stove Through The Wall Through The Wall & Vertical CB 1200 Pellet Stove Vertical Alternate Masonry Masonry 6Mobile Home 7Appliance Set-Up Rear Installation Floor InstallationOutside Air Kit Instructions Rear Vent and Rear Vent to Top Vent Adapter Installation CB 1200 Pellet Stove Top Vent Adapter InstallationInstalling the Top Vent Adapter See Figure Installed Clip Charred Areas in the Back Installing Logo Nickel OnlyTop Log, Left Right Thermostat Installation CB 1200 Pellet Stove Door InstallationTo install door To adjust latches Fuel Size And Material General Operating Information 8Operating Instructions Starting Your First Fire Feed Rate Adjustment Instructions Button. See .1, page 22 . When you press Frequently Asked QuestionsCB 1200 Pellet Stove Ignition Cycles Symptom TroubleshootingPossible Cause Corrective Action Page Page Cleaning or Inspection Quick Reference Maintenance Chart10Maintaining & Servicing Your Appliance Frequency Daily Weekly Monthly Yearly Cleaning Ash Pan Cleaning Firepot with Cleaning Rod & Firepot ScraperCleaning Heat Exchanger Chambers & Drop Tube Ash Removal from Firebox Cleaning Exhaust Path Cleaning Beneath Heat Exchanger Door Latch InspectionCleaning the Hopper Cleaning the Glass Cleaning Exhaust Blower Requires No Lubrication Preparing Firebox for Non-Burn Season Frequency Yearly Cleaning the Top Vent Adapter Convection Blower Replacement CB 1200 Pellet Stove High Ash Fuel Content Maintenance Install new blower Exhaust Blower Replacement Remove existing blowerRe-install blower to blower housing Replacing Side Glass Screws Glass Replacement Component Function & Location Reference Materials Wiring Harness See .1 below Vacuum SwitchSnap Disc #1 Convection Blower 145F Snap Disc #2 Thermostat Override 200F CB 1200 Pellet Stove Component Locations Glass Size Center 13-7/8 wide x 11 high CB 1200 Pellet Stove Exploded ViewsGlass Size Sides 8 wide x 11 high Nbr Description CB 1200 Pellet Stove Item # Parts Alphabetical Order CB 1200 Pellet Stove Service Parts and Accessories Item # Service Parts Alphabetical Order Appliance Accessories Date of Service Performed By Description of Service CB 1200 Pellet Stove Service And Maintenance Log CB 1200 Pellet Stove Homeowner’s Notes CONDITIONS, Exclusions & Limitation of Liability CB 1200 Pellet Stove Warranty Policy Hearth & Home Technologies Limited Warranty Cont’d Contact Information