Main
CLASSIC BAY 1200 PELLET STOVE
Owners Manual
CB1200-B
Installation and Operation
Model:
SAMPLE
and Welcome to the Quadra-Fire Family!
ATTENTION:
CAUTION:
SAMPLE SERIAL NUMBER / SAFETY LABEL LOCATION: Behind left side curtain on outside of hopper wall.
TABLE OF CONTENTS
Section 1: Listing and Code Approvals
Section 2: Getting Started
Section 3: Dimensions & Clearances
Section 4: Vent Information
CB 1200 Pellet Stove
1
C. Glass Specications
A. Appliance Certication
E. BTU & Efciency Specications
CB 1200 Pellet Stove
2
A
. Design, Installation & Location Considerations
B. Fire Safety
CB 1200 Pellet Stove D. Inspect Appliance & Components and Pre-Use Check List
C. Tools And Supplies Needed
September 1, 2008 7014-082D Page 7
CB 1200 Pellet Stove
Figure 7.2 - Top View with Top Vent Adapter
3
A. Appliance Dimensions
28-1/2 in. (724mm)
CB 1200 Pellet Stove
B. Clearances to Combustibles (UL and ULC)
CB 1200 Pellet Stove
Must extend 2 inches (51mm) beyond each side of pipe (shaded area)
C. Hearth Pad Requirements (UL and ULC)
L* K
K M
Hearth Pad Requirements K L* M
CB 1200 Pellet Stove
4
A. Chimney and Exhaust Connection
B. Venting Termination Requirements
CB 1200 Pellet Stove
D. Pipe Selection Chart
C. Equivalent Feet of Pipe
Example of 3 Elbow-Rear Vent Termination Calculaton
5
A
B
C
D
CB 1200 Pellet Stove
Straight Out
B. Through The Wall
45 Degree
CB 1200 Pellet Stove
C. Vertical
D. Through The Wall & Vertical
September 1, 2008 7014-082D Page 15
CB 1200 Pellet Stove
Figure 15.2
F. Alternate Masonry
E. Masonry
6 in. (152mm) Minimum
CB 1200 Pellet Stove
6
You must use a Quadra-Fire Outside Air Kit for installation in a mobile home.
A. Mobile Home Installation
CB 1200 Pellet Stove
7
A. Outside Air Kit Instructions
CB 1200 Pellet Stove
3 to 3 inch Top Vent Adapter 3 to 6 inch Top Vent Offset Adapter
B. Top Vent Adapter Installation
C. Rear Vent and Rear Vent to Top Vent Adapter Installation
CB 1200 Pellet Stove D. Optional Brick Set Installation
E. Brick Clip Installation
CB 1200 Pellet Stove G. Optional Gold or Nickel Grille Assembly
Install Logo
F. Optional Log Set Placement Instructions
LOCATING PINS
Charred Areas in the Back
H. Installing Logo (Nickel Only)
CB 1200 Pellet Stove
J. Thermostat Installation
Hinge
I. Door Installation
Hinge Pin
CB 1200 Pellet Stove
8
A. Fuel Size And Material
B. General Operating Information
WARNING
CB 1200 Pellet Stove E. Fire Characteristics
C. Before Your First Fire
F. Feed Rate Adjustment Instructions D. Starting Your First Fire
CB 1200 Pellet Stove G. Ignition Cycles
H. Frequently Asked Questions
ISSUES SOLUTIONS
Back side of Firepot Firepot floor left open
CB 1200 Pellet Stove
9
Symptom
CB 1200 Pellet Stove Symptom Possible Cause Corrective Action
CB 1200 Pellet Stove Symptoms Possible Cause Corrective Action
CB 1200 Pellet Stove
10
B. Quick Reference Maintenance Chart
C. General Maintenance
A. Proper Shutdown Procedure
Page
Page
Page
CB 1200 Pellet Stove
D. High Ash Fuel Content Maintenance
E. Blower Replacement
F. Bafe Removal
H. Glass Replacement
NOTE:
CB 1200 Pellet Stove
11
A. Component Function & Location
When describing the location of a component, it is always AS YOU FACE THE FRONT OF THE APPLIANCE.
Page
CB 1200 Pellet Stove B. Component Locations
Cleaning Rods
Heat Exchanger Tubes
Page 38 7014-082D September 1, 2008
CB 1200 Pellet Stove
Figure 38.1 - Door, Face, Glass & Door Latch Assembly
Figure 38.2 - Firepot, Igniter & Thermocouple
C. Exploded Views
Glass Size Center: 13-7/8 wide x 11 high Glass Size Sides: 5-1/8 wide x 11 high
Page
Page
September 1, 2008 7014-082D Page 41
D. Service Parts and Accessories
Item # Parts (Alphabetical Order) Part No.
Page 42 7014-082D September 1, 2008
Item # Service Parts (Alphabetical Order) Part No.
September 1, 2008 7014-082D Page 43
Appliance Part No.
Classic Bay 1200 Freestanding Pellet Stove CB1200-B
Accessories Part No.
Page
Page
CB 1200 Pellet Stove G. Warranty Policy
Page
CONTACT INFORMATION:
We recommend that you record the following pertinent information for your CB1200-I PELLET STOVE
NOTICE
DO NOT DISCARD THIS MANUAL
