Condenser Unit, URC-14FE | Hoshizaki KM-1301SRH-E, KM-1301SAH-E

B. Condenser Unit

1. URC-14FE

Units: mm [in.]

TOP VIEW

935

[36-13/16]

850

[33-15/32]

AIR FLOW	700
AIR FLOW	[27-9/16]	AIR FLOW

398 [15-11/16] 380 [14-15/16] 357 [14-1/16]

370 [14-9/16] 435 [17-1/8] 460 [18-1/8]

960

[37-13/16]

FRONT VIEW

907.2

[35-11/16]

557.8	[21-15/16]	68	11/16]
			[2-

380 [14-15/16]

75	309	URC FAN MOTOR CONNECTION
[2-15/16]	[12-3/16]	7/8" DIA OPENING

9

Image 9

Hoshizaki KM-1301SRH-E, KM-1301SAH-E, KM-1301SWH-E service manual Condenser Unit, URC-14FE

Contents

Superior Degree Reliability Hoshizaki AMERICA, INC Contents Page Serious injury Important Safety InformationIndicates important information about the use and care Unit KM-1301SAH-E air-cooled Specifications Icemaker KM-1301SWH-E water-cooled KM-1301SRH-E remote air-cooled URC-14FE Condenser Unit Specifications II. General Information Construction KM-1301SWH-E water-cooled Separators Sequence Cycles and Shutdown Sequence of OperationMinute Fill Cycle Initial Harvest Cycle Freeze Cycle S4 Dip Switch Setting Pump-Out 1st Pump-Out FrequencyPump-Out Cycle Harvest Cycle Cycle at Shutdown Mechanical Bin Control Activation Mechanical Bin Control KM-1301SWH-E, KM-1301SRH-E Cycle Steps Minute Fill Harvest Cycle Sequence Flow ChartPump-Out Cycle Mechanical BC Bin Full Shutdown and Restart Control Board Control Board Control Board Layout No. of Beeps Type of Alarm Every 3 sec LED Lights and Audible Alarm SafetiesSequence Step Time LEDs are On Controls and Adjustments Default Dip Switch SettingsHarvest Timer S4 dip switch 1 Pump-Out Timer S4 dip switch 3 Pump-Out Frequency Control S4 dip switch 5Time seconds Inlet Factory Use S4 dip switch Harvest Pump Timer S4 dip switchFreeze Timer S4 dip switch 9 S4 Dip Switch Setting Pump Motor Time seconds Control Switch Float Switch Control S5 dip switchRefill Counter S5 dip switch 2 through Tank Water Tank Headmaster Service Drier Valve Thermistor Auxiliary Code T-0, U-0 Wiring DiagramsKM-1301SAH-E air-cooled U-0 Auxiliary Code Auxiliary Code U-1 and Later PressureSwitch KM-1301SRH-E remote air-cooled Performance Data 1240 13301780 1335 1142 12701950 2070 Diagnostic Procedure IV. Service DiagnosisPage S4 Dip Switch Setting Pump-Out 1st Pump-Out Frequency Mechanical Bin Control KM-1301SWH-E, KM-1301SRH-E Shutdown Thermostatic Bin Control KM-1301SAH-E Control Board Check Bin Control Check Thermostatic Bin Control Check KM-1301SAH-EMechanical Bin Control Check Stacked Unit Connection Detail Single Unit Connection Detail Mechanical Bin Control Cleaning Float Switch Check Float Switch Check and Cleaning Float Switch Cleaning Thermistor Check Adjustment of Water Regulating Valve water-cooled model Diagnostic Charts No Ice ProductionNo Ice Production Possible Cause No Ice Production Possible Cause Freeze Up Possible Cause Harvest Cycle Freeze Up Freeze Up Possible Cause Freeze Cycle Low Ice Production Low Ice Production Possible Cause Long Harvest CycleLong Freeze Cycle Replacement of Components Service for Refrigerant LinesRefrigerant Recovery Evacuation and Recharge R-404A BrazingPage Component Important Notes for Component Replacement Cleaning Procedure VI. Cleaning and Maintenance Ice Chute Float Switch Assembly Drain Plug Sanitizing Procedure Following Cleaning Procedure Remove the water from the icemaker water supply line Maintenance Drain the water tank