Headmaster Service Drier Valve Thermistor | Hoshizaki KM-1301SRH-E

27

Spray Tubes

Water

Tank

Inlet Water Valve Spray Tubes

Evaporator

Check Valve

Water	Remote Condenser Unit
Water
Supply
	Fan	Fan
		Headmaster
		(C.P.R.)				Service
			Drier			Valve
			Drier
	Thermistor					Access Valve
		Receiver Tank				Access Valve
		Receiver Tank
		Liquid Line				Fusible Plug
		Valve				High-Pressure
						High-Pressure
		Heat Exchanger				Switch
						Hot Gas


			Suction Line			Valve
		Service
		Valve
							Check
							Check
						Strainer	Valves
Float Switch				Service
				Service
				Valve

			Compressor	Discharge Line
			Compressor
Drain

3. KM-1301SRH-E (remote air-cooled)

Water Pump	Expansion Valves

Freeze/Harvest Pump-Out

Pump Timer

Refrigeration Circuit

Water Circuit

Image 27

Hoshizaki KM-1301SRH-E, KM-1301SAH-E, KM-1301SWH-E service manual Headmaster Service Drier Valve Thermistor

Contents

Superior Degree Reliability Hoshizaki AMERICA, INC Contents Page Unit Important Safety InformationSerious injury Indicates important information about the use and care KM-1301SAH-E air-cooled Specifications Icemaker KM-1301SWH-E water-cooled KM-1301SRH-E remote air-cooled URC-14FE Condenser Unit Specifications II. General Information Construction KM-1301SWH-E water-cooled Separators Initial Harvest Cycle Sequence of OperationSequence Cycles and Shutdown Minute Fill Cycle Harvest Cycle S4 Dip Switch Setting Pump-Out 1st Pump-Out FrequencyFreeze Cycle Pump-Out Cycle Cycle at Shutdown Mechanical Bin Control Activation Mechanical Bin Control KM-1301SWH-E, KM-1301SRH-E Mechanical BC Bin Full Shutdown and Restart Sequence Flow ChartCycle Steps Minute Fill Harvest Cycle Pump-Out Cycle Control Board Control Board Control Board Layout Time LEDs are On LED Lights and Audible Alarm SafetiesNo. of Beeps Type of Alarm Every 3 sec Sequence Step Controls and Adjustments Default Dip Switch SettingsHarvest Timer S4 dip switch 1 Pump-Out Timer S4 dip switch 3 Pump-Out Frequency Control S4 dip switch 5Time seconds Inlet S4 Dip Switch Setting Pump Motor Time seconds Harvest Pump Timer S4 dip switchFactory Use S4 dip switch Freeze Timer S4 dip switch 9 Control Switch Float Switch Control S5 dip switchRefill Counter S5 dip switch 2 through Tank Water Tank Headmaster Service Drier Valve Thermistor U-0 Auxiliary Code Wiring DiagramsAuxiliary Code T-0, U-0 KM-1301SAH-E air-cooled Auxiliary Code U-1 and Later PressureSwitch KM-1301SRH-E remote air-cooled Performance Data 1335 13301240 1780 2070 12701142 1950 Diagnostic Procedure IV. Service DiagnosisPage S4 Dip Switch Setting Pump-Out 1st Pump-Out Frequency Mechanical Bin Control KM-1301SWH-E, KM-1301SRH-E Shutdown Thermostatic Bin Control KM-1301SAH-E Control Board Check Bin Control Check Thermostatic Bin Control Check KM-1301SAH-EMechanical Bin Control Check Stacked Unit Connection Detail Single Unit Connection Detail Mechanical Bin Control Cleaning Float Switch Check Float Switch Check and Cleaning Float Switch Cleaning Thermistor Check Adjustment of Water Regulating Valve water-cooled model Diagnostic Charts No Ice ProductionNo Ice Production Possible Cause No Ice Production Possible Cause Freeze Up Possible Cause Harvest Cycle Freeze Up Freeze Up Possible Cause Freeze Cycle Low Ice Production Low Ice Production Possible Cause Long Harvest CycleLong Freeze Cycle Replacement of Components Service for Refrigerant LinesRefrigerant Recovery Evacuation and Recharge R-404A BrazingPage Component Important Notes for Component Replacement Cleaning Procedure VI. Cleaning and Maintenance Ice Chute Float Switch Assembly Drain Plug Sanitizing Procedure Following Cleaning Procedure Remove the water from the icemaker water supply line Maintenance Drain the water tank