Tank | Hoshizaki KM-1301SAH-E, KM-1301SRH-E, KM-1301SWH-E manual

III. Technical Information

A. Water Circuit and Refrigeration Circuit

1. KM-1301SAH-E (air-cooled)

						Hot Gas Valve			Check Valves
					High-Pressure Switch	Hot Gas Valve			Strainer
			Drier						Service Valve
			Drier		Liquid Line Valve	Heat Exchanger	Suction Line		Service Valve
							Suction Line
Water Supply		Inlet Water Valve Tubes Condenser	Fan	Thermistor				Service Valve	Check Valve Float Switch
Water Supply		Inlet Water Valve Tubes Condenser							Check Valve Float Switch
		Spray	Evaporator

Spray Tubes

Discharge Line Compressor

Expansion Valves

Water Pump

Drain

Tank

Water

Pump-Out
Freeze/Harvest	Pump Timer

Refrigeration Circuit

Water Circuit

25

Image 25

Hoshizaki KM-1301SAH-E, KM-1301SRH-E, KM-1301SWH-E service manual Tank

Contents

Superior Degree Reliability Hoshizaki AMERICA, INC Contents Page Serious injury Important Safety InformationIndicates important information about the use and care Unit KM-1301SAH-E air-cooled Specifications Icemaker KM-1301SWH-E water-cooled KM-1301SRH-E remote air-cooled URC-14FE Condenser Unit Specifications II. General Information Construction KM-1301SWH-E water-cooled Separators Sequence Cycles and Shutdown Sequence of OperationMinute Fill Cycle Initial Harvest Cycle Freeze Cycle S4 Dip Switch Setting Pump-Out 1st Pump-Out FrequencyPump-Out Cycle Harvest Cycle Cycle at Shutdown Mechanical Bin Control Activation Mechanical Bin Control KM-1301SWH-E, KM-1301SRH-E Cycle Steps Minute Fill Harvest Cycle Sequence Flow ChartPump-Out Cycle Mechanical BC Bin Full Shutdown and Restart Control Board Control Board Control Board Layout No. of Beeps Type of Alarm Every 3 sec LED Lights and Audible Alarm SafetiesSequence Step Time LEDs are On Default Dip Switch Settings Controls and AdjustmentsHarvest Timer S4 dip switch 1 Pump-Out Frequency Control S4 dip switch 5 Pump-Out Timer S4 dip switch 3Time seconds Inlet Factory Use S4 dip switch Harvest Pump Timer S4 dip switchFreeze Timer S4 dip switch 9 S4 Dip Switch Setting Pump Motor Time seconds Float Switch Control S5 dip switch Control SwitchRefill Counter S5 dip switch 2 through Tank Water Tank Headmaster Service Drier Valve Thermistor Auxiliary Code T-0, U-0 Wiring DiagramsKM-1301SAH-E air-cooled U-0 Auxiliary Code Auxiliary Code U-1 and Later PressureSwitch KM-1301SRH-E remote air-cooled Performance Data 1240 13301780 1335 1142 12701950 2070 Diagnostic Procedure IV. Service DiagnosisPage S4 Dip Switch Setting Pump-Out 1st Pump-Out Frequency Mechanical Bin Control KM-1301SWH-E, KM-1301SRH-E Shutdown Thermostatic Bin Control KM-1301SAH-E Control Board Check Thermostatic Bin Control Check KM-1301SAH-E Bin Control CheckMechanical Bin Control Check Stacked Unit Connection Detail Single Unit Connection Detail Mechanical Bin Control Cleaning Float Switch Check Float Switch Check and Cleaning Float Switch Cleaning Thermistor Check Adjustment of Water Regulating Valve water-cooled model No Ice Production Diagnostic ChartsNo Ice Production Possible Cause No Ice Production Possible Cause Freeze Up Possible Cause Harvest Cycle Freeze Up Freeze Up Possible Cause Freeze Cycle Low Ice Production Possible Cause Long Harvest Cycle Low Ice ProductionLong Freeze Cycle Service for Refrigerant Lines Replacement of ComponentsRefrigerant Recovery Evacuation and Recharge R-404A BrazingPage Component Important Notes for Component Replacement Cleaning Procedure VI. Cleaning and Maintenance Ice Chute Float Switch Assembly Drain Plug Sanitizing Procedure Following Cleaning Procedure Remove the water from the icemaker water supply line Maintenance Drain the water tank