
|
| RULES FOR SAFE OPERATION | |
|
| ||
Battery | ■NEVER Run engine without air filter. Severe engine | ||
| CAUTION: | damage may occur. | |
| ■Always service air cleaner frequently to prevent carburetor | ||
| Never over fill the battery with water above | ||
| malfunction. | ||
| the upper limit. | ||
| ■Always disconnect the battery before performing service | ||
|
| ||
|
| on the generator. | |
|
| ■Always be sure the operator is familiar with proper safety | |
The battery contains acids that can cause injury to the eyes | precaution s and operations techniques before using | ||
generator. | |||
and skin.To avoid eye irritation, always wear safety glasses. | |||
| |||
Use well insulated gloves when picking up the battery. Use | ■Always store equipment properly when not in use. | ||
the following guidelines when handling the battery: | Equipment should be stored in a clean, dry location out of | ||
|
| the reach of children. | |
|
| ■DO NOT leave the generator running in the manual mode | |
|
| unattended. | |
|
| ■DO NOT allow unauthorized people to operate this | |
1. DO NOT drop the battery. There is the possibility of risk | equipment. | ||
■Always read, understand, and follow procedures in | |||
| that the battery may explode. | Operator’s Manual before attempting to operate equipment. | |
2. DO NOT expose the battery to open flames, sparks, | |||
■Refer to the Isuzu Engine Owner's Manual for engine | |||
| cigarettes etc. The battery contains combustible gases | technical questions or information. | |
| and liquids. If these gases and liquids come in contact | ||
| Loading and Unloading (Crane) | ||
| with a flame or spark, an explosion could occur. | ||
|
| ||
3. Always keep the battery charged. If the battery is not | ■ Before lifting, make sure the generator's lifting hook is | ||
| charged a buildup of combustible gas will occur. | secure and that there is no apparent damage to the | |
4. | Always keep battery charging and booster cables in good | generator itself (loose screws, nuts and bolts). If any | |
part is loose or damaged, please take corrective action | |||
| working condition. Repair or replace all worn cables. | ||
| before lifting. | ||
5. Always recharge the battery in an open air environment, | |||
■ Always drain fuel prior to lifting. | |||
| to avoid risk of a dangerous concentration of combustible | ||
| gases. | ■ Always make sure crane or lifting device has been | |
6. In case the battery liquid (dilute sulfuric acid) comes in | properly secured to the hook of guard frame on generator. | ||
■ NEVER lift the machine while the engine is running. | |||
| contact with clothing or skin, rinse skin or clothing | ||
| immediately with plenty of water. | ■ Use adequate lifting cable (wire or rope) of sufficient | |
7. | In case the battery liquid (dilute sulfuric acid) comes in | strength. | |
| contact with your eyes, rinse eyes immediately with | ■ When lifting the generator, always use the balanced | |
| plenty of water, then contact the nearest doctor or hospital, | ||
| and seek medical attention. | ■ NEVER allow any person or animal to stand underneath | |
|
|
the machine while lifting.
■ When loading the generator on a truck, be sure to use the front and back frame bars as a means to secure the generator during transport.
PAGE 8 —