Napoleon Fireplaces GD82PT-PA, GD82NT-PA manual Table of Contents

2

TABLE of CONTENTS

PG2-5	INTRODUCTION		Log Shipping Bracket
	Warranty		Decorative Brick Panel Installation
	Fireplace Dimensions		Log Placement
	Installation Overview		Glowing Embers
	General Instructions		AFK / WI FACE KIT Installation
	General Information	21-22	SERVICING / REPLACEMENTS
	Care of Glass
6-11	VENTING		Glass / Door Replacement
			Blower Replacement
	Vent lengths
			Burner and Valve Replacement
	Venting Specifi cations		Spark Module Battery Replacement
	Minimum Air Terminal Location Clearances		Night LightTM Replacement
12-18	INSTALLATION	22-24	OPERATION
	Wall & Ceiling Protection
	Horizontal Installation		Fireplace Operation
	Vertical Installation		Hand Held Remote Operation
	Using Flexible Vent Components		Operating Instructions
	Horizontal Air Terminal Installation	25	OPERATING INSTRUCTIONS
	Vertical Air Terminal Installation
		26	ADJUSTMENTS
	Fireplace Vent Connection
			Maintenance
	Using Rigid Vent Components
	Horizontal Air Terminal Installation		Pilot Burner Adjustment
	Extended Horizontal Air Terminal Installation		Flame Characteristics
	Vertical Air Terminal Installation		Venturi Adjustment
	Mobile Home	27-28	REPLACEMENTS
	Gas Installation		Ordering Replacement Parts
	Restricting Vertical Vents
			Replacement Parts
	Minimum Framing Clearances
			Flexible Vent Kits
	Minimum Enclosure Clearances
			Terminal Kits
	Minimum Mantel and Enclosure Clearances
			Roof Terminal Kits
18	ELECTRICAL CONNECTION		Accessories
	Hard Wiring Connections	29-30	TROUBLE SHOOTING GUIDE
	Electrical Schematic	31	FIREPLACE SERVICE HISTORY
19-20	FINISHING	32	NOTES

Door Removal

PLEASE RETAIN THIS MANUAL FOR FUTURE REFERENCE

!WARNING

•Do not burn wood or other materials in this fireplace.

•Adults and especially children should be alerted to the hazards of high surface temperatures and should stay away to avoid burns or clothing ignition. Supervise young children when they are in the same room as the fireplace.

•Clothing or other flammable material should not be placed on or near the fireplace.

•Due to high temperatures, the fireplace should be located out of traffic and away from furniture and draperies.

•Ensure you have incorporated adequate safety measure to protect infants/toddlers from touching hot surfaces.

•Even after the fireplace is out, the glass and/or screen will remain hot for an extended period of time.

•Check with your local hearth specialty dealer for safety screens and hearth guards to protect children from hot surfaces. These screens and guards must be fastened to the floor.

•Any safety screen or guard removed for servicing must be replaced prior to operating the fireplace.

•It is imperative that the control compartments, burners and circulating blower and its passageway in the fireplace and venting system are kept clean. The fireplace and its venting system should be inspected before use and at least annually by a qualified service person. More frequent cleaning may be required due to excessive lint from carpeting, bedding material, etc. The fireplace area must be kept clear and free from combustible materials, gasoline and other flammable vapours and liquids.

•Under no circumstances should this fireplace be modified.

•This fireplace must not be connected to a chimney flue pipe serving a separate solid fuel burning appliance.

•Do not use this fireplace if any part has been under water. Immediately call a qualified service technician to inspect the fireplace and to replace any part of the control system and any gas control which has been under water.

•Do not operate the fireplace with the glass door removed, cracked or broken. Replacement of the glass should be done by a licensed or qualified service person.

•Do not strike or slam shut the fireplace glass door.

•This fireplace uses and requires a fast acting thermocouple. Replace only with a fast acting thermocouple supplied by Wolf Steel Ltd.

•Pressure relief doors must be kept closed while the fireplace is operating to prevent exhaust fumes containing carbon monox- ide, from entering into the home. Temperatures of the exhaust escaping through these openings can also cause the surrounding combustible materials to overheat and catch fire.

•Only doors / optional fronts certified with the unit are to be installed on the appliance.

W415-0665 / B / 02.11.08 NOTE: Changes, other than editorial, are denoted by a vertical line in the margin.