Reliance Water Heaters 606, 11-03, 184333-001 guide

Notes

Image 39

Reliance Water Heaters 606, 11-03, 184333-001 instruction manual

Contents

What to do if YOU Smell GAS Used by this Water Heater General Safety Discharge PipeMust not be plugged or blocked Rious Bodily INJURY, or Property Damage General Safety cont’dDEATH, Serious Bodily INJURY, or Property Damage JURY, or Property Damage Table of Contents Introduction Preparing for the New Installation Some models are equipped with Circulating loop fittings Typical Installation Facts to Consider About the Location Locating the New Water Heater Locating the New Water Heater cont’d Facts to Consider About the Location cont’dCombustion Air and Exhaust Wire Fence Air for Ventilation for Appliances Located Confined Spaces18″ Water Piping Installing the New Water Heater Temperature-Pressure Relief Valve Installing the New Water Heater cont’d Filling the Water Heater Wiring Venting Wiring Diagram ALL 75 Gallon Models and 50 Gallon 65,000 BTU/HR Models Venting cont’dALL 40 and 50 Gallon 40,000 BTU/HR Models Venting Through AN Outside Wall Minimum vent length for all models is 18 inches Installing the New Water Heater contdVenting System Example Installations for ALL Models Vent piping can be installed as follows Precautions Cementing PVC, ABS or Cpvc Pipe and FittingsVent Pipe Separation Venting Through a Roof Connecting Vent to BlowerTypical installation Venting contd Venting Through a Roof CONT’D Gas Piping GAS Piping with Flexible Connector GAS Piping with ALL Black Iron Pipe to GAS ControlSediment Trap Model Rating Plate Installation ChecklistBefore Operating the Water Heater Its hookup? ALL Models OperatingBefore the Water Heater will Operate Operation Water Heating Ignition Sequence Make sure gas and electric power are connected properlyOperating cont’d Check for Leaks For Your Safety Read Before Operating Temperature Indicators Temperature Adjustment Buttons Temperature Regulation For Your Information Start Up ConditionsOperational Conditions Operational Conditions cont’d For Your Information cont’d Burner Inspection Periodic MaintenanceBurner Cleaning Venting System Inspection Anode Rod Inspection Periodic Maintenance cont’dTemperature-Pressure Relief Valve Operation Housekeeping Drain Valve Washer Replacement ServiceDraining Leakage Checkpoints Thermostat and GAS Supply Check Troubleshooting Systems Check Troubleshooting cont’d Protection Not EnoughHOT Water Condensation Repair Parts 40 Gal.† Repair Parts cont’dThis is a Repair Parts LIST, not a Packing List Part Part Number Description Repair Parts 50 Gal.† Page