Manuals
/
Reliance Water Heaters
/
Household Appliance
/
Water Heater
Reliance Water Heaters
Comprehensive Guide to the Reliance 606 Water Heater Manual
Models:
11-03
606
184333-001
1
40
40
Download
40 pages
6.32 Kb
33
34
35
36
37
38
39
40
Troubleshooting
Install
Repair Parts
Wiring Diagram
Wire Fence
Maintenance
Temperature Regulation
Drain Valve Washer Replacement
Precautions
Safety
Page 40
Image 40
Page 39
Page 40
Page 40
Image 40
Page 39
Page 40
Contents
Used by this Water Heater
What to do if YOU Smell GAS
Discharge Pipe
General Safety
Must not be plugged or blocked
General Safety cont’d
DEATH, Serious Bodily INJURY, or Property Damage
JURY, or Property Damage
Rious Bodily INJURY, or Property Damage
Table of Contents
Preparing for the New Installation
Introduction
Typical Installation
Some models are equipped with Circulating loop fittings
Locating the New Water Heater
Facts to Consider About the Location
Facts to Consider About the Location cont’d
Locating the New Water Heater cont’d
Combustion Air and Exhaust
Air for Ventilation for Appliances Located Confined Spaces
Wire Fence
18″
Installing the New Water Heater
Water Piping
Installing the New Water Heater cont’d
Temperature-Pressure Relief Valve
Wiring
Filling the Water Heater
Wiring Diagram
Venting
Venting cont’d
ALL 40 and 50 Gallon 40,000 BTU/HR Models
Venting Through AN Outside Wall
ALL 75 Gallon Models and 50 Gallon 65,000 BTU/HR Models
Installing the New Water Heater contd
Venting System Example Installations for ALL Models
Vent piping can be installed as follows
Minimum vent length for all models is 18 inches
Cementing PVC, ABS or Cpvc Pipe and Fittings
Precautions
Vent Pipe Separation
Connecting Vent to Blower
Typical installation
Venting contd
Venting Through a Roof
Gas Piping
Venting Through a Roof CONT’D
GAS Piping with ALL Black Iron Pipe to GAS Control
GAS Piping with Flexible Connector
Sediment Trap
Installation Checklist
Before Operating the Water Heater
Its hookup?
Model Rating Plate
Operating
Before the Water Heater will Operate
Operation
ALL Models
Make sure gas and electric power are connected properly
Operating cont’d
Check for Leaks
Water Heating Ignition Sequence
For Your Safety Read Before Operating
Temperature Regulation
Temperature Indicators Temperature Adjustment Buttons
Start Up Conditions
For Your Information
Operational Conditions
For Your Information cont’d
Operational Conditions cont’d
Periodic Maintenance
Burner Cleaning
Venting System Inspection
Burner Inspection
Periodic Maintenance cont’d
Temperature-Pressure Relief Valve Operation
Housekeeping
Anode Rod Inspection
Service
Drain Valve Washer Replacement
Draining
Leakage Checkpoints
Troubleshooting
Thermostat and GAS Supply Check
Troubleshooting cont’d
Systems Check
Not Enough
HOT Water
Condensation
Protection
Repair Parts
Repair Parts cont’d
This is a Repair Parts LIST, not a Packing List
Part Part Number Description
40 Gal.†
Repair Parts
50 Gal.†
Page
Top
Page
Image
Contents