Reliance Water Heaters 184333-001, 606, 11-03 specs

Notes

Image 38

Reliance Water Heaters 184333-001, 606, 11-03 instruction manual

Contents

Used by this Water Heater What to do if YOU Smell GAS Must not be plugged or blocked General SafetyDischarge Pipe JURY, or Property Damage General Safety cont’dDEATH, Serious Bodily INJURY, or Property Damage Rious Bodily INJURY, or Property Damage Table of Contents Preparing for the New Installation Introduction Typical Installation Some models are equipped with Circulating loop fittings Locating the New Water Heater Facts to Consider About the Location Combustion Air and Exhaust Locating the New Water Heater cont’dFacts to Consider About the Location cont’d 18″ Wire FenceAir for Ventilation for Appliances Located Confined Spaces Installing the New Water Heater Water Piping Installing the New Water Heater cont’d Temperature-Pressure Relief Valve Wiring Filling the Water Heater Wiring Diagram Venting Venting Through AN Outside Wall Venting cont’dALL 40 and 50 Gallon 40,000 BTU/HR Models ALL 75 Gallon Models and 50 Gallon 65,000 BTU/HR Models Vent piping can be installed as follows Installing the New Water Heater contdVenting System Example Installations for ALL Models Minimum vent length for all models is 18 inches Vent Pipe Separation PrecautionsCementing PVC, ABS or Cpvc Pipe and Fittings Venting contd Connecting Vent to BlowerTypical installation Venting Through a Roof Gas Piping Venting Through a Roof CONT’D Sediment Trap GAS Piping with Flexible ConnectorGAS Piping with ALL Black Iron Pipe to GAS Control Its hookup? Installation ChecklistBefore Operating the Water Heater Model Rating Plate Operation OperatingBefore the Water Heater will Operate ALL Models Check for Leaks Make sure gas and electric power are connected properlyOperating cont’d Water Heating Ignition Sequence For Your Safety Read Before Operating Temperature Regulation Temperature Indicators Temperature Adjustment Buttons Operational Conditions For Your InformationStart Up Conditions For Your Information cont’d Operational Conditions cont’d Venting System Inspection Periodic MaintenanceBurner Cleaning Burner Inspection Housekeeping Periodic Maintenance cont’dTemperature-Pressure Relief Valve Operation Anode Rod Inspection Draining Drain Valve Washer ReplacementService Leakage Checkpoints Troubleshooting Thermostat and GAS Supply Check Troubleshooting cont’d Systems Check Condensation Not EnoughHOT Water Protection Repair Parts Part Part Number Description Repair Parts cont’dThis is a Repair Parts LIST, not a Packing List 40 Gal.† Repair Parts 50 Gal.† Page