Manuals / Scotsman Ice / Kitchen Appliance / Ice Maker

Scotsman Ice CME1656R, CME1356R specifications Sensor Holder, Push to Release Photo-Eye Module

Models: CME1656R CME1356R

1 47

Download 47 pages 16.42 Kb

Page 47

Image 47

Sensor Holder

The new ice sensor’s have a photo-eye module that can be separated from the holder.

Once separated, the lenses of the photo-eyes can easily be cleaned with a soft cloth or cotton swab. Ice machine cleaner may be used if needed.

Like the other style of sensor, the photo-eye part can be placed in the reservoir when the ice machine is being cleaned with ice machine cleaner.

When re-assembling, be sure that the wire is not sticking out past the edges of the sensor holder.

Push to Release Photo-Eye

Module

Photo-Eye Module Separated

from Holder

Route Wire Under Clip, Push

Module Into Place

Page 47

Image 47

Scotsman Ice CME1656R, CME1356R Sensor Holder, Push to Release Photo-Eye Module, Photo-EyeModule Separated from Holder

Contents

Introduction CME1356R and CME1656RCME1356R and CME1656R SpecificationsPLAN VIEW CME1356R and CME1656RCondenser and Ice Machine Layouts May PageSerial Number Plate Pre-InstallationCME1356R and CME1656R CME1356R and CME1656R Location & AssemblyRoute Bin Thermostat Bulb Into Bin Bin Control InstallationUse This Table to Adjust Thermostat CME1356R and CME1656RAttach Bracket to Bottom of Ice Machine CME1356R and CME1656RMount Bulb Attach Thermostat Bulb to BracketStacking - Kit KSCME6-LG-B CME1356R and CME1656RFront-to-Back CME1356R and CME1656RGasket on Plastic Walls of Lower Unit Gasket for Metal Edges of Bottom UnitCME1356R and CME1656R For The Installer Remote CondenserDo NOT CME1356R and CME1656RRemote Condenser Location Calculation FormulaRotate Swivel Nut ¼ Turn More CME1356R and CME1656RCoupling Instructions Tighten Swivel NutHead Pressure Control Add-OnKit CME1356R and CME1656RElectrical CME1356R and CME1656RWater Filters CME1356R and CME1656RSupply DrainFinal Check List CME1356R and CME1656RAfter Utility Connections Component Location and Function CME1356R and CME1656RAutoIQ Controller CME1356R and CME1656RFreeze Cycle CME1356R and CME1656RInitial Start Up Initial Start 30 secondsTypical Ice Level When Unit Shuts Off AdjustmentsIf there was a problem during Initial Start Up How to Adjust the Amount of Water PurgeCME1356R and CME1656R 8 7 6How To Operate The AutoIQ Controller Refrigeration System Refrigeration SchematicCME1356R and CME1656R How The Electronic Cuber WorksB. High Voltage CME1356R and CME1656RWater System A. 24 voltAutoIQ Controller Operation, Beginning freeze CME1356R and CME1656RTechnicians Only Freeze Cycle Sequence Refrigeration CME1356R and CME1656RHarvest Water LightCME1356R and CME1656R Sanitation and CleaningIn Place Cleaning of the Ice Machine Water System To drain reservoir if desired Additional MaintenanceCME1356R and CME1656R To Properly Place the Evaporator CoversCME1356R and CME1656R Additional Maintenance Water DistributorsCME1356R and CME1656R Additional Maintenance Inlet Water Valve ScreenCME1356R and CME1656R Additional Maintenance Ice Sensors, CondenserTo Clean the Remote Air Cooled Condenser Possible Cause Service Diagnosis Diagnostic Light AnalysisProblem or Symptom CME1356R and CME1656RPossible Cause Service DiagnosisProblem or Symptom CME1356R and CME1656RPossible Cause Service Diagnosis ComponentsProblem or Symptom CME1356R and CME1656RProbable Correction Problem or SymptomCME1356R and CME1656R Possible CauseCME1356R and CME1656R Diagnosis 1. Disconnect electrical powerHi Pressure Control - Automatic Reset Typical Compressor Amps, single phaseTypical Compressor Amps, three phase Typical Harvest Ice WeightHi Pressure Control - Automatic Reset Typical Compressor Amps, single phaseTypical Compressor Amps, three phase Typical Harvest Ice WeightCME1356R and CME1656R Removal and ReplacementWater Level Sensor/Float Stem CME1356R and CME1656RCME1356R and CME1656R Removal and Replacement AutoIQ ControllerCME1356R and CME1656R Removal and Replacement Water Level SensorTransformer and Compressor Starting Components CME1356R and CME1656RRefrigerant Low Side Access ValveLiquid Line Access Valve CME1356R and CME1656RLiquid Charging CME1356R and CME1656RTo Shut the Machine Off To Manually Reset the machineCME1356R and CME1656R Check the followingBulletin Date SERVICE BULLETINBulletin Number PSPhoto-EyeModule Separated from Holder Route Wire Under Clip, Push Module Into PlaceSensor Holder Push to Release Photo-Eye Module