Controls Central Control Board CCB | State Industries SUF100150

ULTRAFORCE COMMERCIAL GAS WATER HEATER

SUF 120 thru 400 SERVICE HANDBOOK

CONTROLS – CENTRAL CONTROL BOARD – CCB

The Central Control Board or CCB is contained in the housing shown below. Access to the board and the wiring harness plugs can be accomplished by removing two Phillips screws holding the cover.

This view shows the cover removed from the CCB.

Remove these

screws to release

cover

The CCB is controlled by the settings given through the desk top menu (UIM). The CCB also

monitors all pressure switches, the hot surface

igniter, tank temperatures, the gas valve, the This is the back of the UIM. anodes, and the flame sensor.

The CCB directly controls blower speed on the SUF199 and 250 models and indirectly controls blower speed on the SUF 400 by means of a Variable Frequency Drive (see page 33).

Note: Improper operation may be the result of a loose connection. Please check all wiring connections and the power supply to the water heater.

State Water Heaters – Technical Training Department 22

Ashland City, Tennessee © 2009

Servicing should only be performed by a Qualified Service Agent

198152-002

Image 23

State Industries SUF100150, SUF100199 manual Controls Central Control Board CCB, Remove these Screws to release Cover

Contents

Service Handbook Ultraforce Commercial GAS Water Heater Table of Contents Qualifications Introduction Digital Multimeter Tools Required General Information GAS Pressure Specifications High Altitude Installations SUF 120 Adjustment Procedure GAS Pressure SUF120 and 150 Models GAS Orifice High Altitude Installation SUF 300,400 High Altitude Adjustment SUF 300,400 Installation Tips SUF 300 Vent Length Table Equivalent Feet Meters 300,400 Venting Tables SUF 120Vent Length Table Equivalent Feet Meters 120 through Venting Tables SUF 300,400 Venting ALL Models Single Pipe Power Vent Using Room AIR Venting ALL Models TWO Pipe Direct Vent Using Outside AIR Vent Termination Direct Vent ALL Models Direct Venting ALL Models Status Description Icon Control Overview ALL Models Display Adjusting Tank Temperature Operating SET Point Differential Changing the Display Units Fault and Warning Conditions Advanced Diagnostic Information Access to the Current Fault or Warning Viewing Information About the Water Heater Control Sequence Typical ALL Models Control Sequence Flow Chart Remove these Screws to release Cover Controls Central Control Board CCB Controls GAS Valve SUF Important Note High Altitude Installation SUF 120 thru 400 Service Handbook Controls GAS Valve SUF 199 Supply gas pressure Orifice Chart SUF 300,400 Controls GAS Valve , Orifice CHART- SUF300,400 Blocked Outlet Proving Switch Controls Pressure Switches ALL Models Top View of Pressure Switches Blocked Inlet Pressure Switch Odel Pressure Controls Pressure Switches SUF 300,400 Ultraforce Commercial GAS Water Heater Flame Sensor HOT Surface Igniter / Flame Sensor / Control TimingControl Timing Model Blower Speed Control SUF 199 LI1 LI2 LI3 LI4 Blower Motor Wires Black White REDGround HOT Neutral AI1 400 Variable Frequency Drive Blower Speed and Pressure ReadingsVoltage Frequency Speed Instructions VFD Model SUF Wiring Diagram SUF 120 Wiring Diagram SUF Tennessee Waltz Parkway Ashland City, TN