Vermont Castings Jefferson Direct Vent/Natural Vent Gas Heater
| PILOT ADJ |
|
Left Burner Leg | TPTH |
|
|
| |
Injector Shoulder | TP |
|
|
| |
90° | TH | ST228 |
| ||
|
| |
Fig. 43 | Attach switch wires to valve. |
|
Install the Stove Front
|
|
| The Front Plate attaches to the stove by four steel tabs | |
| ST353 | that engage with corresponding cast ribs on the sides | ||
|
|
| and bottom of the stove body. Position the Front about | |
Fig. 41 Be sure to maintain 90° angle at left burner leg. | ||||
3Ó down from stove top and lift the plate to engage the | ||||
|
|
| upper tabs behind the adjacent ribs on the sides. (Fig. | |
| Complete the Assembly |
| ||
|
| 44) Then lower the plate into position, so that the | ||
|
|
| ||
• Open the swiveling latches (cams) on the top left | lower tabs engage with the corresponding ribs at the | |||
| and right corners of the glass frame. | bottom. (Fig. 45) | ||
• Position the glass and frame against the firebox by | When properly installed, the bottom of the Stove Front | |||
| placing the bottom edge on the brackets on the | cannot be pulled away from the sides without also | ||
| bottom face of the firebox. | lifting it. | ||
|
|
|
•Swing the assembly against the firebox, and close
the latches firmly against the pins protruding from | Upper Tabs |
the firebox top. |
|
Install ON/OFF Switch
The switch assembly parts are found in the parts bag. |
| 3Ó |
| |
1. Attach switch assembly to left rear side of stove |
|
|
| |
shroud using two screws and existing holes in |
|
|
| |
shroud. (Fig. 42) |
|
|
|
|
2. Run wires down back of stove, under bottom of rear |
|
|
| |
shroud to valve. |
|
| Control Door |
|
3. Attach wires to valve terminals. (Fig. 43) |
|
| Lower Tabs Engage | ST229 |
|
|
| Ribs in Bottom | |
|
| Fig. 44 Install Stove Front. |
| |
Switch | Existing |
|
|
|
Assembly |
| Side Rib |
| |
Holes |
|
| ||
|
|
| ||
|
|
| Front Tab | Stove Side |
|
|
|
| |
Screws | ST315 | Stove Front | ST279 | |
| ||||
Fig. 42 Attach switch assembly to rear shroud. |
| Fig. 45 | Engage with side ribs. |
|
|
|
|
20002191 | 23 |