Craftsman 580.7524 owner manual Engine Maintenance Vvarnng, Changing OH, Service Air Cleaner

Page 16

ENGINE MAINTENANCE

VVARN[NG

WHEN ADJUSTING OR MAKmNGREPAIRS TO YOUR PRESSURE WASHER

Disconnect the spark plug wire from the spark plug and place the wire where it cannot contact spark plug.

WHEN TESTBNGFOR ENGINE SPARK Use approved spark plug tester.

DO NOT check for spark with spark plug removed,

Checking 0+[ Level

Oi[ level should be checked prior to each use or at least every 5 hours of operation. Keep o+l level maintained.

Changing OH

Change engine oil after the first 5 hours and every 50 hours thereafter. If you are using your pressure washer under extremely dirty or dusty conditions, or in extremely hot weather, change oil more often.

[ ,A cAu++o.

•Used motor oil has been shown to cause skin cancer in certain laboratory animals,

•Thoroughly wash exposed areas with soap and water,

KEEP OUT OF REACH OF CHILDREN.

DON'T POLLUTE. CONSERVE

RESOURCES. RETURN USED OIL TO

COLLECTION CENTERS.

5.Wipe dipstick clean, insert it into oil fill hole and tighten securely, remove dipstick. Add recommended oil up to "Full" mark on dipstick.

Pour slowly. Wipe dipstick clean each time oil level is checked. DO NOT overfill.

6.[nstail oil fill plug and dipstick, tighten securely.

7.Wipe up any remaining oil.

8.Reconnect spark plug wire to spark plug.

Service Air Cleaner

Your engine will not run properly and may be damaged if you run it with a dirty air cleaner.

Service the air cleaner once every 25 hours of operation or once each year, whichever comes first. Service more often if operating under dirty or dusty

conditions. Replacements are ava+iabie at your local Sears service center.

To service the air cleaner, follow these steps:

1.Loosen screw and tilt cover down.

Tabs and Slots

Cartridge

Base

ScrewCover

Change oHwhile engine is still warm from running, as follows:

1.Drain fuel tank by running pressure washer until fuel tank is empty.

2.Disconnect spark plug wire and keep it away from spark plug.

3.Clean area around oil fill, remove oil fill cap/dipstick. Wipe dipstick clean.

4.Tip your pressure washer to drain oi[ from oi[ fiJ[ into a suitabJe container making sure you tip your unit away from spark plug. When crankcase is empty, return pressure washer to upright position.

2.Carefully remove cartridge assembly.

3.To clean cartridge, gently tap pleated paper side on a flat surface.

4.Reinstall clean or new cartridge assembly inside cover.

5.Insert cover's tabs into slots in bottom of base.

6.Tilt cover up and tighten screw securely to base.

NOTE: You can purchase new air filter elements by ca[i+ng 1-800-366-PART.

16

Page 15 Page 17
Image 16
Page 15 Page 17
Contents Horsepower 2800 PSI Safety Assembly Operation Maintenance o Parts EspaSolGPM Model No SEARS, Roebuck and CO., Hoffman Estates, IL 60179 U.S.AHazard Symbols and Meanings Sears, Roebuck and Co., Dept WA, Hoffman Estates, LWhen Adding or Drainbng Fuel When Transporting or Repairbng EquipmentWARNtNG Vhen Starting EquipmentWhen Testing for Engine Spark Pressure WasherKnow Your Pressure Washer Remove Pressure Washer from Carton Carton ContentsAssembling Your Pressure Washer When Adding Fuel Add Engine OilCheckust Before Starting CAUTtONConnect Hose and Water Supply to Pump Pressure Washer Location HOW to USE Your Pressure WasherTo Start Your Pressure Washer How to Stop Your Pressure Washer How To Use the Adjustable NozzleAppmying Detergent with the Adjustabme Nozzme VvarningPressure Washer Rinsing Automatic Cool Down System Therma ReliefProduct Specifications Power RatingsPressure Washer Specifications Engine SpecificationsOwners RESPONSIBILmES General RecommendationsEmission Control Before Each USEPressure Washer Ring Maintenance Nozzle MaintenancePump Maintenance Service Air Cleaner Engine Maintenance VvarnngChanging OH Service Spark Pmug Spark Arrester ServiceCarburetor Air Cooing SystemAfter Each USE Winter StorageLong Term Storage Protect Fuel SystemChange Oil Oil Cylinder BoreProblem CorrectionPage Base Manifold Engine 7 HP, Briggs and Stratton, 12G612 E×poded View 276 188 443 ENGINE, 7 HP, Briggs and Stratton, 12G612 E×poded View842 Overhaul KiT 633 633A 163 127 137 564358 511005 122 524ENGINE, 7 HP, Briggs and Stratton, 12G612 Parts ListPTO Page Emissions Durability Period and Air index Information On Your Engine Emissions LabeSimboos De Peigro y Significados Sears, Roebuck and Co., Dept WA, Hoffrnan Estates, mL60179Peligro ADVERTENCiAUando Opere EL Equipo Cuando Transporte O Repare EL EquipoAdvertencia Cuando Ajuste O Haga Reparaciones a SUConozca SU MAQUiNA Lavadora DE Alta Preson Palanca de Control de la Lvula de Regulaci6n Filtro de AireCONTENtDO DE LA Caja RETtRE LA MAQUtNA Lavadora a Presion DE LA CajaMontaje DE LA MAQUtNA Lavadora a PrestonAgregue Aceite de Motor Agregue GasolinaCuando Anada Combustible NuncaPrecaucion Usta DE REViSiON Prevja ALArranque DEL Motor Conecte maManguera y e Suministro de Agua a a BombaLAVA,DORA a Preston PrecaucknUbicaci6n de Lavadora a Presi6n C6mo Darle Arranque a su Mquina Lavadora a Presi6nC6mo Usar la Boquilla Ajustable C6mo Detener su Mquina Lavadora a Presi6nNota Aplicaci6n del Detergente Usando la Boquilla Ajustable PRECAUCtONImportante Enjuaqe de la Mquina Lavadora a Presion Sistema de Enfriamiento Automtico Alivio TrmicoESPECIFICACtONES DEL Informacion TgCNICA Sobre ELProducto Responsabiudades DEL Propietario RECOMENDACmONES GeneralesControl DE EMlStONES Antes DE Cada USOMantenimiento DE LA Maquina Mantenimiento de los Anilos O Mantenimiento de a BoquilaMantenimiento de la Bomba Mantenim Ento DEL Motor Revisi6n de Nive de AceiteCambio de Aceite Servicio de Depurador de AireRempmace a Buia CarburadorServicio del Apagachispas Sistema de Refrigeraci6n de AireDespues DE Cada USO InwernoAlmacenamiento Prolongado OtrosDetergente no se mezca con eJ rociado Fast RapidoEmisiones Page For Sears professional installation of home appliances For repair in your home of all major brand appliancesItems like garage door openers and water heaters Sears Parts and Repair Center
Top Page Image Contents