Briggs & Stratton 30325 manual Engine Technical Information, Product Specifications, Power Ratings

Page 13

SPECIFICATIONS

ENGINE TECHNICAL

INFORMATION

This is a single cylinder, overhead valve(OHV), air cooled engine. It is a low emissions engine.

In the State of California, Model Series 200000 engines are certified by the California Air Resources Board to meet emissions standards for 250 hours. Such certification does not grant the purchaser, owner or operator of this engine any additional warranties with respect to the performance or operational life of this engine.The engine is warranted solely according to the product and emissions warranties stated elsewhere in this manual.

Power Ratings

*The power ratings for an individual engine model are initially developed by starting with SAE (Society of Automotive Engineers) code J1940 (Small Engine Power & Torque Rating Procedure) (Revision 2002-05). Given both the wide array of products on which our engines are placed, and the variety of environmental issues applicable to operating the equipment, it may be that the engine you have purchased will not develop the rated horsepower when used in a piece of power equipment (actual “on-site” power).This difference is due to a variety of factors including, but not limited to, the following: differences in altitude, temperature, barometric pressure, humidity, fuel, engine lubrication, maximum governed engine speed, individual engine to engine variability, design of the particular piece of power equipment, the manner in which the engine is operated, engine run-in to reduce friction and clean out of combustion chambers, adjustments to the valves and carburetor, and other factors.The power ratings may also be adjusted based on comparisons to other similar engines utilized in similar applications, and will therefore not necessarily match the values derived using the foregoing codes.

PRODUCT

SPECIFICATIONS

Generator Specifications

Starting Wattage

.8,550 Watts

Wattage

5,550 Watts

Rated AC Load Current:

 

At 120 Volts

. .46.2 Amps

At 240 Volts

. .23.1 Amps

Phase

. . . .1–phase

Rated Frequency

. . .60 Hertz

Fuel Capacity

7 U.S. gallons

Shipping Weight

. . . .140 lbs.

Engine Specifications

Gross* Horsepower . . . . . . . . . . . . . . . . . . 10 at 3600 rpm Bore . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3.12 in. (79mm) Stroke . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2.44 in. (62mm) Displacement . . . . . . . . . . . . . . . . . . . . . . 18.64 in. (305 cc)

Spark Plug

Type: . . . . . . . . . . . . Champion RC12YC or Equivalent

Set Gap To: . . . . . . . . . . . . . . . . . . . 0.030inch (0.76mm) Armature Air Gap: . . . . . . . 0.008-0.012 in. (0.20-0.30mm)

Valve clearance with valve springs installed and piston 1/4 in. (6 mm) past top dead center (check when engine is cold).

Intake . . . . . . . . . . . . . . . . . 0.004-0.006 in. (0.10-0.15 mm) Exhaust . . . . . . . . . . . . . . . . 0.004-0.006 in. (0.10-0.15 mm) Oil Capacity . . . . . . . . . . . . . . . . . . .28 Ounces (.83 Liters)

NOTE: For practical operation, the generator load should not exceed 85% of rated wattage. Engine gross horsepower will decrease 3-1/2% for each 1,000 feet (300 meters) above sea level and 1% for each 10° F (5.6° C) above 77° F

(25° C). It should operate satisfactorily at an angle up to 15°.

13

Page 12 Page 14
Image 13
Page 12 Page 14
Contents Operator’s Manual Manual del Operario Starting WattsCall Generator Helpline Llame Línea Directa del Generador Safety Rules Table of ContentsEquipment Description When Starting Equipment When Adding or Draining FuelWhen Operating Equipment When Transporting or Repairing EquipmentWhen Testing for Engine Spark When Adjusting or Making Repairs to Your GeneratorRecoil Starter Know Your GeneratorInstall Wheel Kit AssemblyRefer to and install the wheel kit as follows Always wear eye protection when installing/removing e-ringsAdd Engine Oil Before Starting the EngineAdd Fuel Type of FuelConnecting to a Building’s Electrical System Using the GeneratorSystem Ground Generator LocationStarting the Engine Operating GeneratorGenerator Adapter Cord SET Connecting Electrical LoadsStopping the Engine Do not Overload the GENERATOR. See Don’t Overload Generator120/240 Volt AC, 30 Amp, Locking Receptacle ReceptaclesVolt AC, 20 Amp, Duplex Receptacles Dont Overload Generator Power ManagementCapacity ExamplePower Ratings Product SpecificationsGenerator Specifications Engine SpecificationsGenerator Cleaning Generator MaintenanceGeneral Recommendations Servicing Air Cleaner Engine MaintenanceOil Changing Engine Oil To service the air cleaner, follow these stepsServicing Spark Arrester Carburetor Adjustment Clean Cooling SystemClean and inspect the spark arrester as follows Servicing Spark PlugLong Term Storage Instructions StorageProtect Fuel System GeneratorTroubleshooting Owner’s Warranty Responsibilities Emissions Control System WarrantyPage Page Limited Warranty Tabla DE Contenidos Conserve Estas InstruccionesDescripción DEL Equipo Reglas DE SeguridadCuando Ponga EN Funcionamiento EL Equipo Cuando Añada Combustible O Vacíe EL DepósitoCuando Opere EL Equipo Cuando Transporte O Repare EL EquipoCuando Ajuste O Haga Reparaciones a SU Generador PrecauciónCuando Pruebe LA Bujía DEL Motor Tomacorriente con Dispositivo de Seguridad de Conozca SU GeneradorDesembalaje del Generador MontajeInstale el Juego de Ruedas Tornillos Tuerca de Seguridad AsaAgregar Aceite al Motor Antes DE Darle Arranque AL MotorAgregue Combustible Cuando Añada CombustibleTierra del Sistema USO DEL GeneradorUbicación del Generador Conexión al Sistema Eléctrico de un EdificioEncienda el Motor Operando EL GeneradorConexion De Cargas Electricas Juego DE Cables DEL Adaptador DEL GeneradorParado Del Motor No Sobrecargue EL GENERADOR.Vea No Sobrecargue Generador120/240 Voltios AC, 30 Amp, Receptáculo de Seguridad Receptáculos PrecauciónVolt AC, 20 Amp, Receptáculos Dobles Juego de Cable de 4 Alambres 240V 120V Neutro CargadoCapacidad No Sobrecargue GeneradorControl de la Energía EjemploEspecificaciones DEL Producto Información Técnica Sobre EL MotorPotencia Nominal Especificaciones del GeneradorMantenimiento DEL Generador Recomendaciones GeneralesLimpieza del Generador Aceite Mantenimiento DEL Motor AdvertenciaServicio del Depurador de Aire Limpie la Pantalla Apagachispas Cambio de Aceite del MotorCartucho TapaSistema de Refrigeración de Aire Limpie/Reemplace la BujíaCompruebe la Holgura de la Válvula Ajuste del CarburadorAlmacenamiento Para Periodos Prolongados AlmacenamientoProteja el Sistema de Combustible GeneradorDiagnositicos DE Averías Problemo Causa AccionGarantía DEL Sistema DE Control DE Emisiones = 250 horas, B = 500 horas y a = 1000 horas Uso comercial Uso del consumidor
Top Page Image Contents