Sharp AR-162S Ingredients CAS No Proportion, Other Limits, Routes of Entry, Skin? Ingestion?

Date Issued: Nov. 1, 2000

MATERIAL SAFETY DATA SHEET

MSDS No. F-30991

Section 1.	Product Identification
Product
AR-201ND/DV/SD (Black Developer)
Section 2.	Supplier’s Name and Address
Sharp Corporation
22-22 Nagaike-cho, Abeno-ku, Osaka, Japan
Local suppliers are listed below. Please contact the nearest supplier for additional information.
		(Country)				(Name and Telephone Number)
		U.S.A.			Sharp Electronics Corporation
					Telephone number for information:			1-800-237-4277
					Emergency telephone number:			1-800-255-3924
		Canada			Sharp Electronics of Canada Ltd.
					Telephone number for information:			905-890-2100
					Emergency telephone number:			1-800-255-3924
		United Kingdom			Sharp Electronics (U.K.) Ltd.
					Telephone number for information:			01923-474013
Section 3.	Ingredients
Ingredients				CAS No.		Proportion	OSHA PEL	ACGIH TLV	Other Limits
Iron powder			7439-89-6			> 92.5%	Not listed	Not listed		None
Styrene-Acrylate copolymer			29497-14-1			< 7.0%	Not listed	Not listed		None
Carbon black			1333-86-4			< 0.5%	3.5mg/m3	3.5mg/m3		None

Section 4. Hazardous Identification (Emergency Overview)

Developer is a black powder containing small amounts of toner, and possessing no immediate hazard. There are no anticipated carcinogenic effects from exposure based on animal tests performed using toner.

Section 5. Health Hazard Data

Route(s) of Entry:	Inhalation?	Skin?	Ingestion?
	No	No	Possible but very unusual.
Health Hazards:	Acute oral toxicity ------------ LDL0 of this toner which is included in this developer is over
		2,000mg/kg.
	Mutagenicity ------------------ The toner, which is included in this developer, has been tested on
		Ames test. The result is negative.
Carcinogenicity: In 1996 the IARC reevaluated carbon black as a Group 2B carcinogen (possible human
	carcinogen). This classification is given to chemicals for which there is inadequate human
	evidence, but sufficient animal evidence on which to base an opinion of carcinogenicity. The
	classification is based upon the development of lung tumors in rats receiving chronic inhalation

exposures to free carbon black at levels that induce particle overload of the lung. Studies performed in animal models other than rats did not show any association between carbon black and lung tumors.

While there have been no studies to date using developer, a two-year cancer bioassay using a typical toner preparation containing carbon black (a small amount of toner is included in the developer mixture) demonstrated no association between toner exposure and tumor development in rats.

Signs and Symptoms of Exposure: Minimal irritation to respiratory tract may occur as with exposure to any

	non-toxic dust.
Medical Conditions Generally Aggravated by Exposure:		None
Emergency and First Aid Procedures:
Inhalation;	Remove to fresh air. If effects occur, consult medical personnel.
Eye;	In case of contact, immediately flush eyes with water for 15 minutes.

61