Dell XFR D630 service manual Revision A01

Page 100

DellTM XFR D630 Fully Rugged Notebook Service Manual

Ensure cables are properly routed.

2.Complete the seating of the system board and again verify the cables are in the correct positions, and the 3 gaskets for the power port, rear USB port and side USB port are correctly positioned.

3.Secure the system board using the 4 M2.5 x 5-mm screws (labeled with silver triangles on the system board).

4.Reconnect the cables near the WLAN card and the modem connector to the system board.

5.Reconnect the fan cable to the system board.

6.Install the processor (see Installing the Processor).

7.Install the processor thermal-cooling assembly (see Installing the Processor Thermal-Cooling Assembly).

8.Install any smart cards or smart card blanks into the smart card slot.

9.Install the PC card reader (see Installing the PC Card Reader Cage).

10.Install the speaker (see Installing the Speaker).

11.Install any wireless communication cards (see WWAN, FCM & SIM Cards, Wireless Local Area Network (WLAN) Cards, Internal Card with Bluetooth® Wireless Technology).

12.Install the palm rest (see Installing the Palm Rest).

13.Install the memory module (see Memory).

14.Install any media bay devices (see XBay Devices).

15.Install the keyboard (see Keyboards).

16.Install the hinge cover (see Installing the Hinge Cover).

17.Install the HDD (see Hard Drive).

Page 100 of 106

Revision A01

Image 100

Contents DellTM XFR D630 Fully Rugged NotebookRevision A01 Table of Contents 10.10 24.1 Before You Begin Recommended ToolsTurning Off Your Computer Before Working Inside Your ComputerRevision A01 Screw Chart Screw Image Part Number DescriptionSCR,M3X14,PHH,MSCR,ZPS,XFR CSK Screw M3 X 10 -BLACK SCR,M2.5X5,PHH,TF,BCS PAN Head Screw M2 X 8-BLACK XBay Devices Hard Drive Revision A01 Revision A01 Replacing the Stylus Clip Close Up View of Installed Stylus Clip Handle Replacing the StylusInstalling the Handle Removing the HandleComms Door Port CoversRemoving the Comms Door Docking Door Installing the Comms DoorRemoving the Docking Door Revision A01 Installing the Docking Door VGA Door Removing the VGA DoorRevision A01 Installing the VGA Door Removing the Power Door Power DoorInstalling the Power Door XBay Door Removing the XBay DoorInstalling the XBay Door Audio Ports/WiFi Door Removing the Audio Ports/WiFi DoorInstalling the Audio Ports/WiFi Door USB Side DoorInstalling the USB Side Door Removing the USB Side DoorUSB Rear Door Removing USB Rear DoorPC Card Slot Door Installing USB Rear DoorRemoving the PC Card Slot Door Installing the PC Card Slot Door Hinge Cover Removing the Hinge CoverRevision A01 Installing the Hinge Cover KeyboardsStandard Keyboard Removing the Standard KeyboardRevision A01 Rugged Keyboard Installing the Standard KeyboardRemoving the Rugged Keyboard Revision A01 Revision A01 Installing the Rugged Keyboard KYBD, 87, US, ENG, RGD, XFR Rubber keyboard stiffener bar Revision A01 Connectors should not stack above this level Revision A01 Revision A01 Revision A01 Memory Dimm aMemory module Dimm a Dimm B Screws Memory module cover Display Assembly Removing the Display Assembly Revision A01 Revision A01 Revision A01 Installing the Display Assembly Revision A01 Removing the Display Bezel Installing the Display Bezel Removing the Display PanelRevision A01 Installing the Display Panel Installing the Display Top Cover Removing the Display Top CoverRemoving the Display Latch Installing the Display Latch Internal Card with Bluetooth Wireless TechnologyRemoving the Bluetooth Wireless Card Installing the Bluetooth Wireless Card WWAN, FCM & SIM Cards Mobile Broadband Network Wwan CardWwan card Antenna cable connectors Metal securing tabs Wwan with Passthu Board & Passthru Cable Flash Cache Module Removing the Flash Cache ModuleInstalling the Flash Cache Module Subscriber Identity Module SIM Card Coin-Cell Battery Removing the Coin-Cell BatteryInstalling the Coin-Cell Battery Palm Rest Removing the Palm RestRevision A01 Installing the Palm Rest Underside of Palm Rest showing Touchpad Cable RouteWireless Local Area Network Wlan Cards Removing the Wlan CardWlan card Antenna cable connectors Metal securing tabs Installing the Wlan Card Modem Removing the ModemProcessor Thermal-Cooling Assembly Installing the ModemRemoving the Processor Thermal-Cooling Assembly Installing the Processor Thermal-Cooling Assembly Processor Removing the ProcessorInstalling the Processor PC Card Reader Removing the PC Card Cage Speaker Installing the PC Card CageRemoving the Speaker 21 Fan Installing the SpeakerRemoving the Fan Installing the Fan System Board Removing the System BoardWlan Revision A01 Installing the System Board Revision A01 Revision A01 Flashing the Bios From a CD Flashing the BiosFlashing the Bios From the Hard Drive RF Passthru Board Removing the RF Passthru BoardInstalling the RF Passthru Board WwanBottom Chassis Removing the Bottom ChassisInstalling the Modem Cable Installing the Bottom ChassisRemoving the Modem Cable Revision A01