Outback Power Systems FW-SP-250 manual Electrical Connections and LED Indicators, LEDs, Mounting

Page 6

Electrical Connections and LED Indicators

	Each AC and DC wire is marked near the
Figure 2: Wiring designations	terminal end of each wire.
Figure 2: Wiring designations

A

CE

TR

IR

VO

E R

LEDs

DC

AC IN

AC OUT

Figure 3: Surge Protector LEDs

LEDs

•ACTIVE lights are yellow (power is present).

•ERROR lights are red (protection in that circuit is compromised, replacing the surge protector is recommended).

•For the ERROR light to show, its circuit must be powered; its ACTIVE light will also glow.

The FLEXware Surge Protector Specifications

Nominal	Voltage Protection	Maximum	Energy	Frequency	Protection	Protected
Voltage	Level	Surge Current	Rating		Type	Circuit
120-240 VAC	390VAC	30kA per	2500 Joules	50/60 Hz	Thermally	2AC
12-48 VDC	150 VDC	circuit			Fused MOV	1DC

Mounting


•	FW-SP-250		Mounts inside an FW250

•	FW-SP-ACA		Mounts on an FX

•	FW-SP-R (REPLACEMENT)				Mounts inside either the FW250 or the FW-ACA

5

Image 6

Contents

Includes Mounting and Installation Surge Protector About OutBack Power Systems Disclaimer Contact Information Warranty Introduction Dear OutBack CustomerOutback FLEXware Surge Protector ModelsIntroduction LEDs Electrical Connections and LED IndicatorsFLEXware Surge Protector Specifications MountingRemoving and installing FX M5 hex bolts Tools Required to Install PurposeProcedure Underside screw secures FW-SP-ACA to FXRemove these Two M5 hex bolts from the FX Removing various covers from the FXPreparing and installing the FW-SP-ACA onto an FX FW-SP-ACA slides onto the FXFW-SP-ACA slides down FX slots Screws included secure the FW-SP-ACA to an FXFW-SP-250 FW-SP-250FW250 to check the placement of wires and components FW-SP-R Replacement for the FW-SP-ACA or the FW-ACA ProcedureFW-ACA housing Locating pin Figures 12 FW-SP-R and FW-ACA Bracket FW-SP-R LEDsFW-SP-R installed inside the FW-ACA LED labelFW-SP-R Replacement for the FW-SP-250 Securing wires to FX DC terminalsWiring and Connecting the FLEXware Surge Protector FLEXware Surge Protector Wiring DesignationsSystem can now be powered up FLEXware Surge Protector Limited Warranty Revision Surge Protector Limited Warranty Registration Arlington, WASystem Owner 19009 62nd Avenue NE +34