Amana RS3100007 service manual Service, Top Load Washer

Page 1

This Base Manual covers new double front panel series, Top Load Wash Machines.

Refer to individual Technical Sheet for specific information on models.

Service

Top Load Washer

Service Manual for

Amana®

This manual is to be used by qualified appliance technicians only. Amana does not assume any responsibility for property damage or personal injury for improper service procedures done by an unqualified person.

RS3100007

Revision 0

October 1999

Image 1

Contents Top Load Washer ServiceTable of Contents Recognize Safety Symbols, Words, and Labels Important Notices for Consumers and ServicersImportant Information Important Safety Information Model Identification General InformationProper Grounding and Polarization of 120 Volts Wall Outlets Grounding InstructionsGeneral Operation Definition Component Test Procedure Results Component Testing InformationDiagram and Schematic for correct Wire harness Connection Block White Brown Yellow Red Blue Internal Motor Diagram and SchematicBlue White Red BrownViolet Black White YellowBlue White/Black Motor Assembly Three speed motorNo hot water Possible Cause Result Troubleshooting ProceduresNo cold water Possible Cause Result No warm water Possible Cause ResultMotor does not operate Possible Cause Result Timer does not advance Possible Cause ResultConstant agitation Possible Cause Result No agitation Possible Cause ResultConstant spin Possible Cause Result Slow spin or no spin Possible Cause ResultPossible Cause Result Outer tub does not empty Possible Cause Result Washer locks-up or binding Possible Cause ResultExcessive vibration Possible Cause Result Water leaking from outer tub Possible Cause ResultControl Hood Assembly Disassembly ProceduresTimer Control Hood End PanelsTemperature and Speed Switch Rocker Switch Pressure SwitchGraphic Panel Loading DoorAgitator Agitator, Drive Bell and Seal AssemblyInstalling Drive Bell Front Panel Service Access PanelMotor and Mounting Bracket Pump Mounting screws Rear Pump leg Assembly Reassembly of Pump and BeltEmbosses Motor Assembly Pump and Belt RemovalMotor Switch Motor DisassemblyMotor Drive Pulley Idler Lever and PulleyMixing Valve Door SwitchCabinet Top Washtub and Balance Ring Tub Cover and GasketOuter Tub Drive Pulley, Helix and Brake Weldment and Bearing Assembly Upper Bearing Assembly Transmission AssemblyFriction Ring Appendix a Installation Instructions Tub Wall Unit StandpipeProng grounded outlet only Positionwasher and LevelInstallation Summary Observe all local codes and ordinances Adjustable leg Extension KitSiphon Break Kit Longer Water Inlet HosesInstallation Requirements Appendix B Top Loading Washer Thank you for buying an Amana washer Recognize Safety Symbols, Words, LabelsImportant Safety Information Starting the Wash Close washer lid Starting the Wash contdWhat do the little numbers mean? CyclesDispensers Clean softener dispenser after each use. Remove dispenserFollow the Colors Features, Hints, and CareCold Storage and Non-Use Periods Moving and StorageTopic Possible Cause Solution Trouble ShootingWater Trouble Shooting contdRepairs resulting from the following Amana Washer WarrantyAppendix C Top Loading Washer ContentsRecognize Safety Symbols, Words, Labels Important Safety InformationParts and Accessories Asure Extended Service PlanImportant Information Thank you for buying an Amana washer Save Time and MoneyElectrical Requirements Before You InstallWater Supply Requirements Low Standpipe Installation Washer DimensionsLocation RisersHOT Cold Wall Unit Questions?To Wash Clothes Operating Instructions Washer Control PanelEx-Large Full Warm/ColdOperating Instructions Resetting Timer Helpful Hints and FeaturesPauses Bleach DispenserSafety Spin Care and CleaningAutomatic Balance System General Washer CareTopic Possible Cause Solution Before Calling ServiceTopic Possible Cause Solution Cold Weather Care Cold Storage and Non-Use PeriodsCold Weather Storage Vacations and Extended Non-UseWarranty Provides For WarrantyOwner’s Responsibilities See manual for details Fast Track for Installing Washer