American Dryer Corp EURO-24 manual Scraping noise from basket tumbler area

Page 55

2.Back draft damper is sticking in partially closed position.

S.Scraping noise from basket (tumbler) area...

1.Check for object caught in basket (tumbler)/wrapper area.

2.Basket (tumbler) is out of proper alignment ...

a.Check both vertical and lateral alignment.

b.Check gap between front panel and basket (tumbler) front...set screws may have come loose, and basket (tumbler) walked forward or backwards.

3.Loose basket (tumbler) tie rod.

4.Failed basket (tumbler) support.

T.Excessive noise and/or vibration...

1.Dryer not leveled properly.

2.Impellor (fan/blower) out of balance ...

a.Excessive lint build up on impellor (fan/blower).

b.Failed impellor (fan/blower).

3.Loose basket (tumbler) tie rod.

4.Basket out of adjustment, or adjustment bolts (hardware) are loose.

5.Failed basket (tumbler) support.

6.Loose motor mount.

7.Failed idler and/or tumbler bearings.

8.V-belt(s) either too tight or too loose.

U.Main burners are burning with a yellow flame (for GAS MODELS ONLY)...

1.Burner air shutters are out of adjustment.

2.Insufficient make-up air.

3.Dust and/or lint in burner.

4.Excess gas pressure (see gas information section under Installation Procedures).

51

Image 55

Contents EURO-24 Retain This Manual In a Safe Place For Future Reference For Your Safety Page Table of Contents Routine Maintenance Important Information SectionPersonal Injury or Fire could Result Safety PrecautionsStandards Specifications SpecificationsSpecifications UNPACKING/SETTING UP Installation ProceduresLocation Requirements Dryer Enclosure Requirements Fresh AIR Supply Exhaust Requirements Single Dryer Venting Illus. B Multiple Dryer Common Venting ILLUS. D Important Venting Reminders Electrical Information Must be Provided Black White Green Neutral Important a Circuit Serving Each Dryer Must be Provided Important a Circuit Serving Each Dryer Must be Provided EURO-24 GAS EURO-24 Steam Electrical Service Specifications PER DryerInjury and Improper Operation of the Dryer GAS Information14.92 29.9 mb 26.1 mbPage Page 862 KPa Steam InformationPage Compressed AIR Supply AIR Pressure Page Steam Damper Air Piston Flow Control Operation Adjustment Preparation for OPERATION/START-UP GAS Models only Preoperational TestsBasket Coating Preoperational InstructionsPage OPL Models Shut Down Instructions Service SERVICE/PARTS InformationParts Returning Warranty Parts Warranty InformationReturning Warranty Cards WarrantyPage Cleaning Routine MaintenanceLubrication AdjustmentsLint Drawer Removal No L.E.D. light emitting diode display TroubleshootingDrive motor not operating does not start Blower motor not operating does not start Microprocessor controller computer display reads door Microprocessor computer display reads dSFLPage Failed oven contactor/relay Failed heat selector switch Condensation on main door glass Dryer operates but is taking too long to dryExcessive noise and/or vibration Scraping noise from basket tumbler areaDrive motor only not operating Heating unit not operating ALL temperature selectionsBlower motor only not operating Dryer operates but is taking too long to dry load Heat unit not operating for only one 1 temperature selectionSail switch is fluttering for GAS and Electric Models only Data Label Technical InformationData Label Timing Legend Reversing Timer SPIN/DWELL AdjustmentsProcedure for Functional Check Replacement Components Page ADC 08/03/99-25 01/18/00-25 07/14/00-20