American Dryer Corp EURO-24 manual Sail switch is fluttering for GAS and Electric Models only

Page 58

2.Steam damper binding in partially open position (for STEAM MODELS ONLY).

3.Lint and/or dust accumulation on steam coil fins (for STEAM MODELS ONLY).

4.Housekeeping ...

a.Lint drawer and lint compartment not being cleaned on a regular basis.

b.Lint accumulation in location exhaust system.

5.Insufficient make-up air.

6.Failed hi-limit thermostat (for GAS and ELECTRIC MODELS ONLY).

7.Failed lint compartment automatic (225º F [107º C]) safety thermostat circuit.

8.Extractors not performing properly.

9.Low and/or inconsistent gas pressure (for GAS MODELS ONLY).

10.Gas supply may have low heating value (for GAS MODELS ONLY).

11.Sail switch is fluttering (for GAS and ELECTRIC MODELS ONLY) ...

a.Restriction in location exhaust system.

12.Fault in electric oven element circuit (for ELECTRIC MODELS ONLY) ...

a.Failed element(s).

b.Failed oven contactor (relay).

13.Exceptionally cold/humid or low barometric pressure atmosphere.

14.Blower (impellor/fan) motor rotation direction is incorrect.

I.Dryer is cycling on hi-limit thermostat (for GAS and ELECTRIC MODELS ONLY)...

1.Blower (impellor/fan) motor failure.

2.Blower (impellor/fan) motor rotation direction is incorrect.

3.Insufficient make-up air.

4.Restriction in location exhaust system ...

a. Undersized exhaust ducting.

5.Lint drawer needs cleaning.

6.Failed hi-limit thermostat.

7.Failed oven contactor (relay) - (for ELECTRIC MODELS ONLY).

54

Image 58

Contents EURO-24 Retain This Manual In a Safe Place For Future Reference For Your Safety Page Table of Contents Routine Maintenance Section Important InformationSafety Precautions Personal Injury or Fire could ResultStandards Specifications SpecificationsSpecifications Installation Procedures UNPACKING/SETTING UPLocation Requirements Dryer Enclosure Requirements Fresh AIR Supply Exhaust Requirements Single Dryer Venting Illus. B Multiple Dryer Common Venting ILLUS. D Important Venting Reminders Electrical Information Must be Provided Black White Green Neutral Important a Circuit Serving Each Dryer Must be Provided Important a Circuit Serving Each Dryer Must be Provided Electrical Service Specifications PER Dryer EURO-24 GAS EURO-24 SteamGAS Information Injury and Improper Operation of the Dryer26.1 mb 14.92 29.9 mbPage Page Steam Information 862 KPaPage Compressed AIR Supply AIR Pressure Page Steam Damper Air Piston Flow Control Operation Adjustment Preparation for OPERATION/START-UP Preoperational Tests GAS Models onlyPreoperational Instructions Basket CoatingPage OPL Models Shut Down Instructions Service SERVICE/PARTS InformationParts Warranty Warranty InformationReturning Warranty Cards Returning Warranty PartsPage Routine Maintenance CleaningAdjustments LubricationLint Drawer Removal No L.E.D. light emitting diode display TroubleshootingDrive motor not operating does not start Blower motor not operating does not start Microprocessor computer display reads dSFL Microprocessor controller computer display reads doorPage Failed oven contactor/relay Failed heat selector switch Dryer operates but is taking too long to dry Condensation on main door glassScraping noise from basket tumbler area Excessive noise and/or vibrationDrive motor only not operating Heating unit not operating ALL temperature selectionsBlower motor only not operating Heat unit not operating for only one 1 temperature selection Dryer operates but is taking too long to dry loadSail switch is fluttering for GAS and Electric Models only Technical Information Data LabelData Label Reversing Timer SPIN/DWELL Adjustments Timing LegendProcedure for Functional Check Replacement Components Page ADC 08/03/99-25 01/18/00-25 07/14/00-20