American Dryer Corp Super AD-30 manual Table of Contents

Page 5

Table of Contents

SECTION I
IMPORTANT INFORMATION		3
A. RECEIVING and HANDLING		3
B. SAFETY PRECAUTIONS		4
SECTION II
SUPER AD-30 SPECIFICATIONS		6
SECTION III
INSTALLATION PROCEDURES		8
A. UNPACKING/SETTING UP		8
B. LOCATION REQUIREMENTS		9
C. DRYER ENCLOSURE REQUIREMENTS		10
D. FRESH AIR SUPPLY		11
E. EXHAUST REQUIREMENTS		12
F. ELECTRICAL INFORMATION		18
G. GAS INFORMATION		24
H. STEAM PIPING INFORMATION		28
I.	PREPARATION FOR OPERATION	32
J.	PREOPERATIONAL TESTS	33
K. PREOPERATIONAL INSTRUCTIONS		35
L. SHUT DOWN INSTRUCTIONS		38
SECTION IV
SERVICE/PARTS INFORMATION		39
A. SERVICE		39
B. PARTS		39
SECTION V
WARRANTY INFORMATION		40
A. RETURNING WARRANTY CARD(S)		40
B. WARRANTY		40
C. RETURNING WARRANTY PARTS		40
SECTION VI
ROUTINE MAINTENANCE		42
A. CLEANING		42
B. ADJUSTMENTS		43
C. LUBRICATION		43

Image 5

Contents Super AD-30 Retain This Manual In a Safe Place For Future Reference For Your Safety Page Table of Contents Troubleshooting Important Information SectionWhat to do if YOU Smell GAS Safety PrecautionsPage Specifications Super AD-30 SpecificationsSpecifications UNPACKING/SETTING UP Installation ProceduresSection D Location RequirementsDryer Enclosure Requirements Fresh AIR Supply Exhaust Requirements Single Dryer Venting Illus. B Multiple Dryer Common Venting ILLUS. D Important Venting Reminders Electrical Information Page Green Phase 3ø Hookup for GAS and Steam Dryers only Page Super ADG-30DS Gas Reversing Super ADS-30DS Steam Reversing GAS Information Piping/Connections Page Page Steam Information Page 90 psi Normal 80 psi70 psi Page Preparation for Operation Preoperational Tests Page Preoperational Instructions Page OPL Models Shut Down Instructions Parts SERVICE/PARTS InformationService Returning Warranty Cards Warranty InformationWarranty Returning Warranty PartsPage Cleaning Routine MaintenanceLubrication AdjustmentsDrive motor not operating does not start TroubleshootingNo L.E.D. light emitting diode display Blower motor not operating does not start Microprocessor controller computer display reads door Microprocessor computer display reads dSFLPage Dryer operates but is taking too long to dry No heat for Steam Models onlyExcessive noise and/or vibration Condensation on main door glassDryer or scraping noise at basket tumbler area Blower motor only not operating Drive motor only not operatingHeat unit not operating for only one 1 temperature selection Heating unit not operating ALL temperature selectionsFailed hi-limit thermostat for GAS and Electric Models only Dryer operates but is taking too long to dry loadPage Timing Legend Reversing Timer SPIN/DWELL AdjustmentsContact American Dryer Corporation Technical InformationData Label Data Label Microprocessor computer Board Procedure for Functional Check Replacement ComponentsDirect Spark Ignition DSI System