Chromalox CN2110 manual Instrument Power Wiring

Page 15

CN 2110 Temperature Controller

Control Output Wiring

continued

T5 (Solid State Relay, 5 Amps) and

T10 (Solid State Relay, 10 Amps) Output Wiring

Note: CN 2110 model T10 has a fan. CN 2110 model T5 does not have a fan.

Fan

Fuse 120/240

VAC

Neutral

Load

Figure 3.12

Control Output Wiring–T5 and T10

Instrument Power Wiring

Make 120 or 240 VAC instrument power connections to terminals as shown in Figure 3.13.

120/240VAC Neutral Ground

Figure 3.13

90-260 VAC Instrument Power Connections

Alarm Wiring The Form C Relay Output is connected as shown in Figure 3.14.

Alarm Out

C NO NC

COM NO

NC

Figure 3.14

Alarm Connections

Section 3–Installation and Wiring

11

CN 2110

Image 15

Contents User’s Guide Omega.com Table of Contents CN 2110 Temperature ControllerPage Quick Setup Setting the Sensor and Control ModeAdjusting the Set Point Inspection and Unpacking IntroductionModel Identification Sensor and Control Type Selection Switches Installation and WiringRemoving Mounting Collars MountingController will now be held firmly in place Mount the CNGood Wiring Practices Thermocouple Inputs Sensor Input Wiring Sensor Wiring NotesSensor Input Wiring Three-Wire RTD InputsTwo-Wire RTD Inputs Control Output Wiring R20 20 Amp Relay Output WiringDC Solid State Relay Drive, 24Vdc, 40mA Output Wiring Instrument Power Wiring Adjusting Set Point and Configuration Adjusting the Set PointConfiguration 5Move to .6until SP is next menu Displayed Exit ConfigurationSecurity Codes and Levels Configuration MenusOFF Control and Alarm Operation Control Operation Alarm Operation optionalTuning PI Control Removal Module InstallationReplacing Output Modules Module Option DescriptionsAuto Cycle Time ReplacementCalibration Offset Factory Default Recovery To reestablish the factory default valuesCalibration Calibration Factory Calibration Recovery Calibration NotesSensor Calibration Control Adjustments SpecificationsSymptom Probable Cause Correction Steps TroubleshootingFAn FAIL, CN TroubleshootingPage Page Page USAWARRANTY/DISCLAIMER Temperature