Desa VDCFTNA installation manual Parts List

Page 37

PARTS LIST

THERMOSTAT MODELS

This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed under Replacement Parts on page 42 of this manual.

KEY

NO. PART NO. DESCRIPTION

1 111069-01 Dual Burner

2 099056-29 Injector

099056-34 Injector

3 104424-04 Outlet Tube

4 111124-01 Burner Retainer Spring

5 107485-01 ODS Pilot

107486-01 ODS Pilot

6 099387-09 Pilot Tube

7 098249-01 ODS Nut

8 M11084-38 Screw, HWH AB 8-18 x 0.38

9 M11084-26 Screw, HWH AB 10-16 x 0.38

10

**

Chamber Floor

11 097809-02 Male Fitting

12 098867-10 Gas Regulator

098867-14 Gas Regulator

13 108628-02 Inlet Tube

14 102394-02 Control Bracket

15 098522-12 Thermostat Gas Valve

098522-13 Thermostat Gas Valve

16 101381-01 Valve Cover with Piezo

17 101628-03 Flexible Connector

18 099211-01 Screw, HWH AB 10-16 x 2.50

19 098544-01 Thermobulb Clip

20 098271-10 Ignitor Cable

21 111138-01 Log Set

PARTS AVAILABLE - NOT SHOWN

VDCFTPA •

•

•

•

•

•

•

•

•

•

•

•

•

•

•

•

•

•

•

•

•

VDCFTNA •

•

•

•

•

•

•

•

•

•

•

•

•

•

•

•

•

•

•

•

•

QTY

1

1

1

1

1

1

1

1

2

2

10

1

1

1

1

1

1

1

1

1

1

2

1

1

1

901056-01	Brass Flare Adapter Fitting
103470-01	Hardware Pack
100563-01	Warning Plate
101054-01	Lighting Instruction Plate

** Not a field replacement part

•

•

•

•

•

•

•

•

1

1

1

1

113133-01C

www.desatech.com

37

Image 37

Contents Thermostat Models Vdcftna and Vdcftpa Remote-Ready Models Shown with Optional Cabinet Mantel/Hearth Base AccessoryVdcfrpa and Vdcfrna Table of Contents Safety Information Safety Information Product Features Optional Remote Control AccessoriesProduct Identification Local CodesAir for Combustion Ventilation Hood AssemblyTools Required Phillips screwdriver Providing Adequate Ventilation AIR for Combustion VentilationDetermining FRESH-AIR Flow for Fireplace Location Ventilation Air From Inside Building Ventilation AIRVentilation Air From Outdoors Check GAS Type InstallationInstallation Items InstallationFireplace Clearances Fireplace pilot and burner must be at least 18 above floorIf you have not installed hood, follow instruc- tions on Built-In Fireplace InstallationRoute flexible gas line through access hole in hearth base Optional Mantel InstallationCheck all gas connections for leaks. See Installing Optional Blower Accessory GA3450TARemoving Upper Louver Remove 4 screws from upper louver see . Save these screws Installing Blower AccessoryOpen lower louver door by swinging door down see Figure Extension Cord For Built-In InstallationExternal Regulator With Vent Pointing Down Connecting to GAS SupplyInstallation Items Needed Connecting equipment shutoff valve to heater controlChecking GAS Connections Equipment Shutoff Valve Pressure Testing Fireplace Gas ConnectionsInstalling 9-Volt Battery in Hand-Held Remote Control Unit Installing ReceiverRemove battery cover on back of remote control unit Replace battery cover onto remote control unitRemove jumper wire from control valve see , Optional Wall Switch GWMS2 Remote-Ready Models OnlyFor Your Safety Read Before Lighting Installing LOG SET and ScreenOperating Fireplace Lighting InstructionsOperating Fireplace Manual Lighting ProcedureTo Turn OFF GAS To Appliance Thermostat Control OperationOperating Blower AUTO/OFF/ON Blower SwitchDepress control knob and light pilot with match Remote Operation Optional Hand-HeldOn/Off Series Model HRC100 Thermostat Series Model HRC200Safety Features Optional GWMS2 Wall Mounted SwitchAuto Shutoff Feature Key Pad Lock FeatureInspecting Burners Cleaning MaintenancePilot Flame Pattern Burner Flame PatternWiring Diagram Cleaning MaintenanceLOG Set CabinetObserved Problem Possible Cause Remedy TroubleshootingTroubleshooting Mote-Ready Models Only Power is low When heated, vapors fromSlight smoke or odor during Initial operation Processes and log curingGas leak. See Warning VDCFTPA, Vdcfrpa SpecificationsFirebox Models VDC Illustrated Parts BreakdownParts List Thermostat Models Illustrated Parts BreakdownVdcftpa and Vdcftna Parts List Vdcfrna and Vdcfrpa REMOTE-READY ModelsKEY Equipment Shutoff Valve GA5010 AccessoriesTHERMOSTAT-CONTROLLED Blower KIT GA3450T WALL-MOUNT ON/OFF Switch AccessoriesReceiver and HAND-HELD Thermostat Remote Control KIT HRC200 Receiver and HAND-HELD Remote Control KIT HRC100Service Hints Replacement PartsTechnical Service Parts Under Warranty113133-01C Keep this Warranty Warranty InformationLimited Warranty VENT-FREE Compact Classic Hearth