Brinkmann Charcoal/Gas Grill owner manual Before Storing Your Grill, Trouble Shooting

Page 21

BEFORE STORING YOUR GRILL:

•Ensure that the cylinder valve is fully closed.

•Clean all surfaces.

•Lightly coat the burners with cooking oil to prevent excess rusting.

•If storing the grill indoors, disconnect the LP tank and leave the LP tank OUTDOORS.

•Place a protective cap cover on the LP tank and store the tank outdoors in a well ventilated area out of direct sunlight.

•Clean burner prior to use after storing, at the beginning of grilling season or after a period of one month not being used. Spiders and insects like to build nests in burner tubes (especially during colder months). These nests can cause fires in burner tubes or under grill.

•If storing the grill outdoors, cover the grill with a grill cover for protection from the weather.

TROUBLE SHOOTING

Problem:

•Burner will not light

•Fire at control knob

•Yellow Flames at burner

•Flame blows out on "LOW"

•Burner does not get hot enough

•Grill is Too Hot

Possible Causes:

1.Check LP cylinder fuel level.

2.Bad electrode spark.

Check to see if the grill will match light. Electrode or collector may need adjustment.

3.Burner may not be properly seated.

4.Burner may be obstructed.

5.The cylinder valve may be closed.

6.Regulator is not properly seated on cylinder valve.

1.Burner holes may be obstructed. See section on "Burner Assembly/Maintenance" under Proper Care and Maintenance.

2.Burner is improperly seated on control valve.

3.Gas connections may be loose.

Leak Check and tighten all connections.

1.Burner is obstructed. See section on

"Burner Assembly/Maintenance" under Proper Care and Maintenance.

1.Burner holes may be obstructed. See section on "Burner Assembly/Maintenance" under Proper Care and Maintenance.

2.Burner is improperly seated on control valve.

1.Flow control device has been activated in regulator. See Regulator Resetting Procedure under Connecting LP Cylinder and Hose/Regulator to Grill.

2.Burner holes may be obstructed.

1.Excess grease build-up causing grease fires.

2.Damaged or faulty regulator.

Replace with factory authorized parts.

3.Cook on a lower temperature setting.

20

Image 21

Contents Professional Dual Zone Important Safety Table of Contents GAS Grill General Warnings LP GAS Cylinder not Supplied with this Grill Installation InformationCylinder Specifications Regulator Resetting Procedure Installing the LP GAS Cylinder Onto the GrillFilling the LP GAS Cylinder Hose and RegulatorConnecting Hose and Regulator Connecting Hose and Regulator to AN LP GAS CylinderLeak Testing When to Perform a Leak TestChecking for Leaks PRE-START Check List Lighting Instructions Lighting the Main BurnersMatch Lighting the Main Burners Operating the Grill Turning OFF the GrillBreaking in Your Grill Preheating the GrillGrilling to Proper Temperature CleanlinessTo Minimize FLARE-UPS Indirect CookingCharcoal Grill General Warnings Page Preheating Your Grill Charcoal Operating InstructionsFlavoring Wood GRILLING/SEARINGTo Increase Heat Adding CHARCOAL/WOOD During CookingTransporting and Storage AFTER-USE SafetyProper Care & Maintenance Cleaning and MaintenanceBurner ASSEMBLY/MAINTENANCE Heat Distribution Plates Cooking GrillsBefore Storing Your Grill Trouble ShootingFrequently Asked Questions Frequently Asked Questions Parts BAG Contents Parts List Assembly InstructionsPage Step Gas Manifold Bottom Door Pivots Top Door Door Grill Body NutAssembly Door Locking Plate AA/1.5V Alkaline Battery Igniter Cap Control Knobs Slide the drawer into the left side table Attach the divider using two M6 X 12mm bolts and two M6 nuts Brinkmann 3248 Assembled Peligro Importantes Advertencias DE SeguridadSección DEL Carbón DE Leña Sección DE LA Parrilla DE GASAdvertencias Generales Para LA Parrilla DE GAS Información DE Instalación Especificaciones DEL Cilindro Manguera Y Regulador Llenado DEL Cilindro DE GAS DE Propano LíquidoConexión DE LA Mangueray Regulador Pruebas DE Detección DE Fugas Cuándo Realizar UNA Prueba DE Detección DE FugasVerificación DE Ausencia DE Fugas ¡PRECAUCIÓN Lista DE Verificación Preliminar AL EncendidoSiga las instrucciones al pie de la letra Instrucciones DE EncendidoOperación DE LA Parrilla Apagado DE LA ParrillaPreparación DE LA Parrilla Para Usarla POR Primera VEZ Precalentamiento DE LA ParrillaCocción Indirecta Para Reducir AL Mínimo LAS LlamaradasLimpieza Cocinar a LA Parrilla a LA Temperatura ApropiadaAdvertencia Advertencia Cómo Precalentar SU Parrilla Instrucciones DE Operación DE LA Parrilla DE Carbón DE LeñaLeña QUE Imparte Sabor Cómo Asar Y ChamuscarCómo Incrementar LA Temperatura Cómo Añadir Carbón O Leña Durante EL CocimientoTransporte Y Almacenamiento Cómo Añadir Carbón O Leña Durante EL Cocimiento ContinuadaDebido Cuidado Y Mantenimiento Limpieza Y MantenimientoCómo Ensamblar Y Darle Mantenimiento a LOS Quemadores Placas DE Distribución Térmica Parrillas Para CocinarAntes DE Almacenar SU Parrilla Resolución DE ProblemasPreguntas Frecuentes Preguntas Frecuentes LA Tarjeta DE Piezas Contiene Contenido DE LA Bolsa DE PiezasLista de Piezas Instrucciones DE EnsambladoPage Paso Advertencia Pivotes de La Puerta Inferior Ensamblado del Cuerpo de la Parrilla Pila alcalina AA de Tapa del Ecendedor Perillas de Control Deslice el cajón para meterlo a la mesa lateral izquierda Una el divisor con dos pernos M6 X 12mm y dos tuercas M6 Brinkmann 3248 Armada Warranty