Invacare M51, M50, M61 service manual Electronics, Accessories, Limited Warranty

Page 7

TABLE OF CONTENTS
TABLE OF CONTENTS
SECTION 13—ELECTRONICS	120
Removing/Installing the Joystick	120
Removing	120
Installing	120
Repositioning the Joystick Mounting Bracket	121
Van Seat	121
ASBA Seat	122
Disconnecting/Connecting the Joystick	123
Disconnecting	123
Connecting	123
Adjusting the Quad-Link Retractable Mount	124
Adjusting Lock/Release Tension	124
Replacing the Controller	125
Wire Routing	127
SECTION 14—ACCESSORIES	128
Installing/Removing the Crutch/Cane Holder	128
Installing	128
Installing/Removing the Oxygen Holder	129
Installing/Removing/Using the Walker Holder	130
Installing/Removing the Walker Holder	130
Using the Walker Holder	130
LIMITED WARRANTY	131

Part No. 1125075

7

Pronto® Series

Image 7

Contents Pronto Series M50 M51 M61 Document Part Number Recommended ToolsReference Documents Recommended ToolsTable of Contents VAN Seat ArmsAsba Seat Wheels Front RIGGINGS/FOOTBOARDShrouds and Frame Motors BatteriesLimited Warranty AccessoriesElectronics Special Notes Signal Word MeaningWheelchair TIE-DOWN Restraints and Seat Restraints Special Notes Label Location Medium SEMI-RECLINE Typical Product ParametersAsba Typical Product Parameters Medium General Guidelines Controller Settings/Repair or ServiceOperation Information Batteries Tire PressureImmediately Charging Batteries Grounding InstructionsWeight Limitation Weight TrainingRain Test EMI Information EMI InformationEMI Information Safety Inspection Checklists Safety INSPECTION/TROUBLESHOOTINGAll Wheelchairs Wheels TroubleshootingSolutions Additional Requirements for M61 WheelchairsComments Display Description DefinitionSPJ Information Gauge Display Diagnostics SUB Code Diagnostic CodesDiagnostics Code Possible SolutionE05 Motor/Gearbox/Brake Symptom Probable Cause SolutionsContamination is found. Refer to Replacing Motor Battery Battery Charger M61 Only Checking Battery Charge LevelDON’T Field Load Test Battery Quality Motor TestingWheelchair Operation Turning the Power On/OffM50 and M51 Wheelchairs Manufactured Before 8/15/05 Turn the power On by pressing the On/Off button Using the Joystick to Drive the WheelchairReverse Movement ActionAdjusting the Speed Using the Horn M50 M51 Wheelchairs Manufactured Before 15/05 Using the HornM50/M51 Wheelchairs Manufactured After 8/14/05 and All M61 Elevating the SeatElevating the Seat Joystick SPJJoystick Switches and IndicatorsOn/Off Toggle Switch Speed Control KnobInformation Gauge Display Mode Button SPJ+ and SPJ+ w/ACC Joystick Switches and IndicatorsSpeed Control Buttons Mode ButtonOn/Off Button SpeedometerService Indicator Adjusting Van Seat Arm Width Removing/Installing Van Seat ArmArms Adjusting Van Seat Arm Height Adjustable Height Arms Only Adjusting Van Seat Arm AngleAdjusting Van Seat Arm Height Adjustable Height Arms Only Replacing Van Seat Armrest AssemblyRemoving/Installing Flip Back Armrest Removing/Installing Flip Back ArmrestAdjusting the Flip Back Armrest Height Adjusting the Flip Back Armrest HeightFold Down Back Angle Adjusting the Back AngleVAN Seat Semi-Recline Back AngleRemoving Adjusting the Headrest Semi-Recline OnlyRemoving/Installing the Seat Assembly InstallingRemoving/Installing the Seat Assembly Adjusting Seat DepthAdjusting Seat Depth M50/M51 Wheelchairs Adjusting the Seat HeightSets of Seat Total Number Length of Mounting M61 WheelchairsAdjusting the Seat Height M61 Wheelchairs Adjusting Seat Position on Seat Base Seat Position Weight Seat Post Inch Standard Limitation Mounting HoleReplacing the Seat Positioning Strap Replacing the Seat Positioning StrapAsba Seat M50/51 Wheelchairs Only Adjusting the Seat Height M50/51 Wheelchairs Only Weight Seat Post Seat Depth Limitation Mounting Hole InchM61 Wheelchairs Removing/Installing the Seat Pan Removing/Installing the Seat Frame Adjusting the Seat WidthRemoving/Installing the Seat Frame Adjusting the Seat PositionAdjusting the Seat Position Removing/Installing the Seat Positioning StrapHeight, only new back canes will be needed Back UpholsteryAsba Seat Asba Seat Height Back HeightAdjusting the Back Angle Adjusting the Back Angle Front RIGGINGS/ Footboard Installing/Removing Front RiggingsModel PHWH93 Front Riggings Adjusting Footrest HeightModel PH904A and PHAL4A Front Riggings Replacing Heel LoopsRaising/Lowering Elevating Front Riggings Adjusting/Replacing Telescoping Front Rigging SupportsVan Seats Front Rigging Standard Inch OUT Inches OUT Asba SeatPosition Removing/Installing the Footboard Assembly Angle Adjusting the Footboard AssemblyDepth Adjusting the Footboard Assembly AngleReplacing the Front/Rear Casters WheelsAdjusting Caster Assembly Adjusting Caster AssemblyRemoving/Installing the Front Headtube Assembly Removing/Installing the Front/Rear Caster AssembliesInstalling the Drive Wheel Removing/Installing the Drive WheelRemoving the Drive Wheel Removing/Installing the Drive Wheel Inner Rim Shrouds and Frame Removing/Installing the Top ShroudRemoving/Installing the Top Shroud Removing/Installing the Side ShroudsRemoving/Installing the Side Shrouds Removing/Installing the Front ShroudRemoving/Installing the Front Shroud Removing/Installing the Inner ShroudsRemoving/Installing the Inner Shrouds Removing/Installing the Pivot TubeRemoving/Installing the Pivot Tube Removing/Installing the Walking Beam Removing/Installing the SureStep SpringRemoving/Installing the Walking Beam Removing/Installing the Elevate ActuatorInstalling Removing/Installing the Elevate Actuator Removing/Installing the Actuator Switch Sensor Batteries Removing/Installing Batteries from/into Battery Tray Using the Proper BatteriesBatteries Tool QTY Comments Connecting Battery Cables Connecting/Disconnecting Battery Cables102 Connecting/Disconnecting Battery Cables Charging Batteries Disconnecting Battery CablesBattery Charger Operation On-Board Battery Charger Charging Indicator Status ON/OFF Indicator StatusReplacing the On-Board Battery Charger Fuse Replacing the On-Board Battery Charger Fuse Replacing the On-Board Battery Charger110 Replacing the On-Board Battery Charger Motors Removing/Installing the MotorRemoving/Installing the Motor Engaging/Disengaging Motor Release Lever Engaging/Disengaging Motor Release LeverRemoving/Installing the Motor Release Lever Removing/Installing the Motor Release LeverReplacing Motor Brushes 117 Replacing Motor Brushes Electro-Mechanical Parking Brake TestingElectro-Mechanical Parking Brake Testing Electronics Removing/Installing the JoystickVan Seat Repositioning the Joystick Mounting BracketRepositioning the Joystick Mounting Bracket Disconnecting Disconnecting/Connecting the JoystickConnecting Adjusting Lock/Release Tension Adjusting the Quad-Link Retractable MountReplacing the Controller Adjusting Lock/Release TensionReplacing the Controller Wire Routing Wire RoutingInstalling/Removing the Crutch/Cane Holder AccessoriesHolder Installing/Removing the Oxygen HolderInstalling/Removing the Walker Holder Installing/Removing/Using the Walker HolderUsing the Walker Holder 131 Limited WarrantyUSA

Related manuals

Manual 2 pages 51.97 Kb

Manual 2 pages 41.81 Kb