Invacare 1125078 service manual Removing/Installing the Battery Box on the At’m QT

Page 47

SECTION 8—BATTERIES

	Connector on
Connector on	Battery Box
Battery Tray	(Hidden from View
	Battery Box
	Handle
	Battery Box

Battery Tray

Wheelchair Base

FIGURE 8.3 Removing/Installing the Battery Box on the At’m QT

Removing/Installing the Batteries From/Into the At’m Battery Pack

NOTE: For this procedure, refer to FIGURE 8.4 on page 48.

Removing

1.Remove the battery pack from the wheelchair. Refer to Removing/Installing the Battery Pack on the At’m on page 45.

2.Open the battery pack by performing the following -

A.Grasp the side flaps and pull up.

B.Grasp the front flap and pull up.

3.Disconnect the wiring harness from the batteries in the following order -

A.NEGATIVE (-) BLACK battery cable from the NEGATIVE (-) battery terminal on the left battery.

B.POSITIVE (+) RED battery cable from POSITIVE (+) battery terminal/post on the right battery.

C.WHITE battery cable (jumper) from the POSITIVE (+) battery terminal/post on the left battery and the NEGATIVE (-) battery terminal/post on the right battery.

4.Remove the batteries from the battery pack.

Part No. 1125078

47

At’m and At’m QT

Image 47

Contents At’m and At’m QT Wheelchair Type Electronics Manual Reference DocumentsReference Documents Table of Contents Batteries Table of ContentsArms JoystickANTI-TIPPERS Transporting the Wheelchair Limited WarrantyWheelchair TIE-DOWN Restraints and Seat Restraints Signal Word MeaningSpecial Notes At’m Label LocationAt’m QT Parameters Typical Product ParametersTypical Product Parameters Tire Pressure Repair or Service InformationGeneral Guidelines Batteries Operation InformationOxygen Charging Batteries Rain Test Weight TrainingWeight Limitation Grounding InstructionsEMI Information EMI InformationEMI Information Checklist Safety INSPECTION/TROUBLESHOOTINGWheels TroubleshootingInformation Gauge and Diagnostics Codes Wheels SolutionsDisplay Description Definition Comments SUB Code Diagnostics CodePossible Solution E05 E08 Motor/Gearbox/Brake Symptom Probable Cause SolutionsDamaged connector or worn Down, and recharge the wheelchair overnight with Troubleshooting Battery Troubleshooting Battery Charger DON’T Checking Battery Charge LevelField Load Test Field Load Test Battery QualityElectro-Mechanical Parking Brake Test Electro-Mechanical Parking Brake TestInstalling Footboard AssemblyRemoving/Installing the Footboard Assembly Adjusting Footboard Assembly HeightSeat Removing/Installing the SeatRemoving/Installing the Seat Replacing Seat Positioning Strap Replacing Seat Positioning StrapRemoving/Installing Seat Upholstery Removing/Installing Under-Seat BasketRemoving/Installing Seat Upholstery Replacing the Seat Latches Replacing the Seat LatchesArms Removing/Installing Arm PadsReplacing Clothing Guard Removing/Installing Arm PadsRemoving/Installing Arm Tube Removing/Installing Arm TubeJoystick Disconnecting/Connecting the JoystickDisconnecting ConnectingJoystick Removing/Installing the JoystickRemoving/Installing the Joystick Repositioning the Joystick to Opposite Arm Batteries Recommended Battery TypeRecommended Battery Type Removing/Installing the Battery Pack on the At’mRemoving/Installing the Battery Pack on the At’m Removing/Installing the Battery Box on the At’m QTRemoving/Installing the Battery Box on the At’m QT Negative Black Removing Removing/Installing the At’tm QT Battery Box Assembly Removing/Installing the At’tm QT Battery Box Assembly Charging Batteries Charging Using an Independent ChargerMulti-Function Charger Port At’m Resetting the Circuit BreakerAt’m QT 10 Resetting the Circuit Breaker At’mEngaging/Disengaging the Motors MotorsRemoving/Installing Motor Shroud Removing/Installing Motor ShroudRemoving/Installing the Base Plate Removing/Installing the Base PlateRemoving/Installing MK5 Controller Removing/Installing MK5 ControllerRemoving/Installing MK5 Controller Installing Removing/Installing the MotorsReplacing the Knurled Cylinder Removing/Installing the MotorsMotors Replacing the Knurled Cylinder Front Riggings Installing/Removing the Front Rigging Support BracketsFront Riggings Installing/Removing the Front Rigging AssemblyInstalling/Removing the Front Rigging Assembly Adjusting Footrest HeightReplacing Front Casters Wheels and CastersReplacing Forks Adjusting ForksReplacing Forks Adjusting Forks Removing/Installing the Drive WheelsReplacing Drive Wheels on the Drive Axle Removing/Installing the Drive WheelsANTI-TIPPERS Removing/Installing the Anti-TippersRemoving/Installing the Anti-Tippers- At’m Removing/Installing the Anti-Tippers- At’m QT Transporting the Wheelchair Transporting the WheelchairTransporting the Wheelchair USA Limited Warranty