Craftsman 919.728001, A15256 owner manual Pressure reading

Page 26

 

 

PROBLEM

CAUSE

CORRECTION

 

 

Pressure reading

It is normal for "some"

If there is an excessive amount

 

 

on the regulated

pressure drop to occur.

of pressure drop when the

 

 

pressure gauge

 

accessory is used, adjust the

 

 

 

regulator as instructed in the

 

 

drops when an

 

 

 

 

Operation section.

 

 

accessory is

 

 

 

 

NOTE: Adjust the regulated

 

 

used.

 

 

 

 

pressure under flow conditions

 

 

 

 

 

 

 

 

(while accessory is being

 

 

 

 

used).

 

 

 

 

 

 

 

Air leak from

Possible defect in safety

Operate safety valve manually

 

 

safety valve.

valve.

by pulling on ring. If valve still

 

 

 

 

leaks, it should be replaced.

 

 

 

 

 

 

 

Compressor is

Prolonged excessive use

Decrease amount of air usage.

 

 

not supplying

of air.

Check the accessory air

 

 

enough air

Compressor is not large

 

 

to operate

enough for air requirement.

requirement. If it is higher than

 

 

accessories.

 

the SCFM or pressure supplied

 

 

 

 

by your air compressor, you

 

 

 

 

need a larger compressor.

 

 

 

Hole in hose.

Check and replace if required.

 

 

 

Check valve restricted.

Remove and clean, or replace.

 

 

 

Air leaks.

Tighten fittings.

 

 

 

Restricted air intake filter.

Clean or replace air intake

 

 

 

 

filter. Do not operate the

 

 

 

 

air compressor with the

 

 

 

 

filter removed. Refer to the

 

 

 

 

"Air Filter" paragraph in the

 

 

 

 

Maintenance section.

 

 

 

Loose belt.

Loosen wingnut and then

 

 

 

 

tighten wingnut until it contacts

 

 

 

 

the washer, plus one turn.

 

 

 

 

 

 

 

Restricted air

Dirty air filter.

Clean or replace. See "Air

 

 

intake.

 

Filter" paragraph in the

 

 

 

 

Maintenance section.

 

 

 

 

 

 

 

Regulator knob

Damaged regulator.

Replace.

 

 

has continuous

 

 

 

 

air leak.

 

 

 

 

 

 

 

 

 

Regulator will

Damaged regulator.

Replace.

 

 

not shut off air

 

 

 

 

outlet.

 

 

 

 

 

 

 

A15256

26- ENG

Page 25 Page 27
Image 26
Page 25 Page 27
Contents AIR Compressor Sold by Sears Canada, Inc. Toronto, Ont. M5B 2B8Table of Contents Important Safety Instructions Specification ChartSafety Guidelines Definitions Model No 919-728001Location away from compressor Spray area. An additional length of hoseExplosion May be required Tank is designed to withstand specific Accessories, tires, and other inflatablesSoft tissue damage to exposed skin For essential control of air pressure, youYour specific application Repairs attempted by unqualifiedTo human consumption Hot for several minutes after operation Or attempt maintenance until unit hasResult in serious burns Do not reach around protective shroudsFire, Inhalation, Damage to Vehicle Surfaces Glossary AccessoriesAccessories Duty CycleTo Install Handle AssemblyTools Required for Assembly UnpackingNut Flat Washer Rubber Foot Screw Wheel Shoulder Bolt To Assemble WheelsAssemble Rubber Feet To Add Oil To Pump Risk of Electrical Shock. Improper InstallationLocation of the Air Compressor 120/240 Dual Voltage Motor Extension CordsVoltage and Circuit Protection Operation Know Your Air Compressor Description of OperationBefore Each Start-Up How to StopBefore Starting How to Start Maintenance Customer ResponsibilitiesChecking ChangingAir Filter Inspection and Replacement To Replace BeltAir Compressor Pump Intake and Exhaust Valves Outlet Tube Pressure Relief Tube Nuts Service and AdjustmentsTo Replace or Clean Check Valve Screwdriver Open position nothing is visibleTo Replace Regulator Storage Troubleshooting Pressure reading Problem Cause Correction Problem Cause Correction Table DES Matières Pleine Garantie D’UN ANConsignes DE Sécurité Importantes Tableau DES SpécificationsMesures DE Sécurité Définitions Conserver ces directives Avertissement Risque dexplosion ou dincendie PréventionAvertissement Risque de projection dobjets Avertissement Risque déclatementRisque Prévention Avertissement Risque de choc électrique Avertissement Risque par inhalationAvertissement Risque de chute Avertissement Risque de brûluresAvertissement Risque relié aux pièces mobiles Risque Avertissement Risque dune utilisation dangereuseAccessoires AccessoiresCycle DE Service LexiqueOutils requis pour lassemblage Installation de la poignéeAssemblage DéballageAssemblage des roues Assemblage des pieds en caoutchoucAjout dhuile à la pompe Risque de choc électrique Emplacement du compresseur dairRisque de choc Rallonges Protection contre la surtension et protection du circuitMoteur deux tensions de 120/240 volts Risque dune utilisationDescription du fonctionnement UtilisationFamiliarisez-vous avec votre compresseur dair Interrupteur On/Auto/Off ManostatAvant le démarrage Utilisation de lappareilArrêt de lappareil Procédures de rodage Risque dune utilisationRisque déclatement Une pression dair trop élevée conduit Avant chaque mise en marcheMise en marche Nominale maximumVérification de la soupape de sûreté EntretienResponsabilités du consommateur Vérification Vidange du réservoirHuile ChangementRemplacement de la courroie Filtre à air Inspection et remplacementAlignement de la poulie et du volant-moteur Boulons de la tête du compresseur serrageRemplacement ou nettoyage de la soupape de retenue Entretien ET RéglagesRemplacement du régulateur Rangement Dépannage A15256 58- FR Le moteur ne tourne pas Bruit de cliquetis Canada MY-HOMESears Parts and Repair Center
Top Page Image Contents