Bosch Power Tools 1671 manual Important Charging Notes, Charging Battery Pack BC830 1 Hour Charger

Page 15

BM 2610945718 12-06 12/12/06 12:21 PM Page 15

IMPORTANT CHARGING NOTES

1.The charger was designed to fast charge the battery only when the battery temperature is between 32˚F (0˚C) and 140˚F (60˚C). If the battery pack is too hot or too cold, the charger will not fast charge the battery. (This may happen if the battery pack is hot from heavy use). When the battery temperature returns to between 32˚F (0˚C) and 140˚F (60˚C), the charger will automatically begin charging.

2.A substantial drop in operating time per charge may mean that the battery pack is nearing the end of its life and should be replaced.

3.Remember to unplug charger during storage period.

4.If battery does not charge properly:

a.Check for voltage at outlet by plugging in some other electrical device.

b.Check to see if outlet is connected to a light switch which turns power “off” when lights are turned off.

c.Check battery pack terminals for dirt. Clean with cotton swab and alcohol if necessary.

d.If you still do not get proper charging, take or send tool, battery pack and charger to your local Bosch Service Center. See “Tools, Electric” in the Yellow Pages for names and addresses.

Note: Use of chargers or battery packs not sold by Bosch will void the warranty.

CHARGING BATTERY PACK (BC830 1 HOUR CHARGER)

Plug charger cord into your standard power outlet, then insert battery pack into charger (Fig. 15).

The charger’s green indicator light will begin to “BLINK”. This indicates that the battery is receiving a fast charge. Fast-charging will automatically stop when the battery pack is fully charged.

When the unit beeps and the indicator light stops “BLINKING” (and becomes a steady green light) fast charging is complete.

The battery pack may be used even though the light may still be blinking. The light may require more time to stop blinking depending on temperature. When you begin the charging process of the battery pack, a steady red light

could also mean the battery pack is too hot or too cold.

The purpose of the green light is to indicate that the battery pack is fast-charging. It does not indicate the exact point of full charge. The light will stop blinking in less time if the battery pack was not completely discharged.

When needed, the internal fan of the charger will turn on to aid the charging process and speed.

When charging several batteries in sequence, the charge time may slightly increase.

When the battery pack is fully charged, unplug the charger (unless you're charging another battery pack) and slip the battery pack back into the tool.

FIG. 15

BATTERY

PACK

RED LIGHT

CHARGER

GREEN LIGHT

-15-

Image 15
Contents Read Before Using Personal safety General Safety RulesWork area safety Electrical safetyPower tools are dangerous in the hands of untrained users Power tool use and careBattery tool use and care ServiceKeep hands away from Danger cutting area and blade Safety Rules for Circular SawsCutting procedures Kickback and related warningsLower guard function Battery/Charger Battery CareExplode LITHIUM-ION Batteries Battery DisposalSymbols Lock Button Ventilation SAW HookLift Lever Foot ButtonMark Outer Wrenchwasher Outer Washer AssemblyAttaching the Blade VARI-TORQUE ClutchOperating Instructions Depth Bracket Adjustment Lever ONE Tooth Length shouldSafety Switch Safety Switch Release Button Cutting Angle CheckGeneral Cuts Bevel Adjustment Knob Line GuideVertical Cuts Bevel Cuts Switch BrakeDesired Width CUT RIP Board Guide Plunge CutsCutting Large Sheets Wrong Foot Lower Guard Lift Lever Right RIP CutsInserting and Releasing Battery Pack Battery Charged Condition IndicatorGreen Indicator Lights RED Button Temperature Indicator LightCharging Battery Pack BC830 1 Hour Charger Battery Pack RED Light Charger Green LightImportant Charging Notes Maintenance AccessoriesCleaning Sécurité personnelle Consignes générales de sécuritéSécurité du lieu de travail Sécurité électriqueUtilisation et entretien des outils Électroportatifs Utilisation et entretien des outils à pilesEntretien Consignes de sécurité pour scies circulaires Procédures de coupeAvertissements relatifs aux rebonds et Problèmes associés Le plomb provenant des peintures à base de plomb Fonction du garde inférieurEntretien des piles Chargeur de pileMise au rebut des piles Ne tentez pas dePiles LITHIUM-ION Symboles Scies circulaires sans fil Description fonctionnelle et spécificationsGraduation Rondelle Cléextérieure AssemblageMontage DE LA Lame Embrayage « VARI-TORQUE »Vérification DE L’ANGLE DE Coupe Consignes de fonctionnementRéglage DE LA Profondeur DE Coupe Bouton DEInterrupteur Réglage DE LA Coupe EN BiseauGuide D’ALIGNEMENT CoupesCoupes DE Refente Coupes EN GuichetCoupe DE Grandes Feuilles Placez le panneau ou la planche sur des supports situésTémoin DE Température Témoins DE CHARGE, Symboles ET SignificationTémoin DE Pile Chargée Témoins Verts BoutonRemarques Importantes Concernant LA Charge Chargement DU BLOC-PILES Chargeur DE 1 Heure BC830BLOC-PILES Voyant Rouge Chargeur Vert Accessoires EntretienNettoyage Seguridad personal Normas generales de seguridadSeguridad del área de trabajo Seguridad eléctricaMecánicas Uso y cuidado de las herramientas Alimentadas por bateríasServicio de ajustes y reparaciones Normas de seguridad para sierras circulares Procedimientos de corteEl retroceso y advertencias relacionadas Función del protector inferior Cuidado de las baterías Batería/cargadorBaterías DE Iones DE Litio Eliminación de las bateríasSímbolos Con aislamiento dobleDe Li-ion Sierras circulares sin cordón Descripción funcional y especificacionesMarca Arandela Llaveexterior EnsamblajeColocacion DE LA Hoja Embrague DE PAR Motor VariableGatillo Instrucciones de funcionamientoAjuste DE Profundidad Interruptor DE SequridadGuia DE Interruptor Ajuste DE InclinacionCuadrante Pomo DE Ajuste DE Inclinacion Guía DE Línea Cortes Verticales InclinadosCortes AL Hilo Cortes POR PenetraciónCorte DE Planchas Grandes IncorrectoIntroducción Y Suelta DEL Paquete DE Baterías Indicador DE Estado DE Carga DE LA BateríaLuces Indicadoras Verdes Boton LUZ Indicadora DE LA TemperaturaNotas Importantes Para Cargar Carga DEL Paquete DE Baterías Cargador DE 1 Hora BC830Paquete DE Baterías LUZ Roja Cargador Verde Limpieza MantenimientoAccesorios ServicioRemarques Notas Limited Warranty of Bosch Portable and Benchtop Power Tools