New Buck Corporation 32 manual Servicing, Repair Parts

Page 36

SERVICING

SERVICING

Repair and replacement work should only be performed by a qualified service technician.

Always shut off the gas supply and make sure heater is cool before beginning any service operation. Check for gas leaks after servicing.

REPAIR PARTS

A parts list with exploded view follows. Always include correct name, part number, and model number of the heater when ordering service parts. Please contact your local dealer or Distributor when ordering, or if one is not available, you may contact:

New Buck Corporation

P.O. Box 69

Spruce Pine, NC 28777

(828)-765-6144

Page 34

Image 36

Contents MODEL FREESTANDING FIREPLACE OR WITH ANOPTIONAL WOODEN SURROUND VENT-FREEPage TABLE OF CONTENTS Page SECTION SAFETY INFORMATION WARNINGS Do not try to light any appliance psi 3.5 kPa Figure CEILINGWALL LEFT SIDE7.Place logs on the burner base as shown on page FREESTANDING INSTALLATION MODEL 32 FS WALLWALL ALCOVE INSTALLATION FOR YOUR SAFETYWALL INSTALLATION OF MODEL 32 WS WS ASSEMBLY INSTRUCTIONSWITH OPTIONAL WOODEN SURROUNDKIT#PA-KDM32 Installation” for minimum clearancesINSTALLATION IN RESIDENTIAL OR AFTER-MARKETMOBILE HOMESNOTE: See “Producing Adequate Ventilation” page PRODUCING ADEQUATE VENTILATION DETERMINING FRESH-AIRFLOW FOR HEATER LOCATIONVent-freeheater VENTILATION AIR VENTILATION AIR FROM INSIDE BUILDINGVENTILATION AIR FROM OUTDOORS PREPARING LOG KIT TOP RIGHTTOP LEFT REAR LOG FRONT LOGGAS CONNECTION FLAMEGAS PRESSURE CHECK FOR YOUR SAFETY, READ BEFORE LIGHTING LIGHTING INSTRUCTIONS MILLIVOLT VALVE ITTWHAT TO DO IF YOU SMELL GAS LIGHTING INSTRUCTIONS TO TURN OFF GAS TO APPLIANCE IGNITOR ELECTRODEPILOT BURNER MANUAL LIGHTING PROCEDURE THERMOSTAT CONTROL OPERATIONFOR YOUR SAFETY READ BEFORE LIGHTING LIGHTING INSTRUCTION MODULATING VALVE SITOR MANUAL VALVE SIT LIGHTING INSTRUCTION 12.Close access panel door 13.Turn on all electrical power to the appliancePage MANUAL LIGHTING PROCEDURE THERMOSTAT CONTROL OPERATION15seconds FLAME CHECK FLAMEWIRING DIAGRAM IMPORTANT SAFEGUARDS CLEANINGTROUBLE SHOOTING Air in gas lines when OBSERVED OBSERVED REPAIR PARTS SERVICINGREPLACEMENT PARTS KEY#PART DESCRIPTION PART NUMBERITTGENERAL CONTROLS REPLACEMENT PARTS KEY#PART DESCRIPTION PART NUMBER5 6 13 PagePILOT LIMITED WARRANTY MODEL FP-32 NEW BUCK CORPORATIONPage