Desa LHP) (V)L36(EP, LZPR) installation manual VL32HN, LHN, VL36EN, LEN, VL32HP, LHP, VL36EP, LEP

Page 1

UNVENTED (VENT-FREE) FIREPLACE

OWNER’S OPERATION AND INSTALLATION MANUAL

MANUALLY CONTROLLED	REMOTE CONTROL READY
MODELS	MODELS
NATURAL GAS	NATURAL GAS
(V)L32(HN, LHN)	(V)L36(ZNR, LZNR)
(V)L36(EN, LEN)	(V)L42(ZNR, LZNR)
PROPANE/LP GAS	PROPANE/LP GAS
(V)L32(HP, LHP)	(V)L36(ZPR, LZPR)
(V)L36(EP, LEP)	(V)L42(ZPR, LZPR)

WARNING: If the information in this manual is not fol- lowed exactly, a ﬁre or explosion may result causing property damage, personal injury or loss of life.

—Do not store or use gasoline or other ﬂammable vapors and liquids in the vicinity of this or any other appliance.

—WHAT TO DO IF YOU SMELL GAS

•Do not try to light any appliance.

•Do not touch any electrical switch; do not use any phone in your building.

•Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.

•If you cannot reach your gas supplier, call the ﬁre department.

—Installation and service must be performed by a quali- ﬁed installer, service agency or the gas supplier.

Save this manual for future reference.

For more information, visit www.desatech.com

Image 1

Contents VL36EN, LEN VL32HN, LHNVL32HP, LHP VL36EP, LEPTable of Contents Safety Information Blower Accessory Product FeaturesLocal Codes OperationLocating Firebox Product SpecificationsPlanning Models42 Models Providing Adequate Ventilation AIR for Combustion VentilationDetermining FRESH-AIR Flow for Heater Location Ventilation Air From Inside Building Ventilation AIRInstallation Clearances InstallationVentilation Air From Outdoors Minimum Wall and Ceiling Clearances see ,Example BUILT-IN Firebox InstallationMinimum 16 inches from Side Wall Nails or Wood Screws Nailing Flanges Rough Opening for Installing WallInstalling Cabinet Mantel Installing Firebox Using Optional Accessory MantelsLower Louver Panel Installing Optional Blower AccessoriesDuplex Electrical Outlet Place control knob, provided, onto control shaft see Figure Wiring Diagram Decal 12 Front of BlowerInstalling Fireplace Hood and Screen HARD-WIRING FireboxDuplex Box Handy Box Strain Relief Top View of Rod LayoutInstallation Items Needed Connecting to GAS SupplyVent Pointing Down Propane/LP Checking GAS ConnectionsNatural Test Pressures Equal To or Less Than 1/2 Psig 3.5 kPa Test Pressures In Excess Of 1/2 Psig 3.5 kPaSupply Tank Correct all leaks at onceVintage Oak Two-Piece Log Set Installing LogsLog #2 Log #1 Front Post Chassis PostMetal Ember Bed Base AssemblyPost Metal PostPlace top left log on middle log as shown in Figure Operating FireplaceTop Left Log Top Right Log Middle Left Front Log Right Front LogPress in control knob and turn counter Lighting InstructionsControl Knob Ignitor ButtonREMOTE-READY Models For Your Safety Read Before Lighting Manual Lighting ProcedureVariable Control Operation To Turn OFF GAS To ApplianceBe hot if heater has been running Control Knob Flame Adjustment On Position Follow instructions included with the remote controlOptional Remote Control Optional HAND-HELD Remote OperationThermostat Series Model Ghrctb ON/OFF Series Model GhrcbPilot Flame Pattern Inspecting BurnersFront Burner Flame Pattern Cleaning Logs Cleaning MaintenanceBurner Injector Holder and Pilot AIR Inlet Hole Observed Problem Possible Cause Remedy TroubleshootingLow gas pressure Assembly Clean ODS/pilot seeLeased Long enoughObserve minimum installa When burners are lit Position when burners areBurner backﬁring during com Bustion DamagedGas leak. See Warning Wiring Diagram SpecificationsMaximum Minimum Shipping Weight 104 lbs 184 lbs REMOTE-READY Models onlyTechnical Service Service HintsReplacement Parts Parts Under WarrantyAccessories Illustrated Parts Breakdown Parts Available not Shown Parts List46 39 Parts List 23/24 Not Shown 110314-05 Crossover Log Illustrated Parts Breakdown and Parts ListKEY LOG Part Numbers VL36 Models VL42 Models Description QTY Keep this Warranty Warranty InformationLimited Warranty VENT-FREE Fireplace