CFM Corporation DVT38IN, DVT44IN Chateau, Position the Log Rear Left, 20011956

Page 29

9.Position the Log Rear Left

Figure 45

7.Position the Log Grate Right and Left. Position the right and left grate logs simultaneously on the grate in front of the burner housing by hold- ing the two logs with the narrower end toward the middle and the bark details toward the front. Set the logs and lean forward toward the grate. The outer end of the logs should line up with the grate on the outside. (Fig. 43)

8.Position the Log Rear Right . Posi- tion the log rear right by holding the log at an angle with the pointed end down toward the bottom. Set the

Figure 43

Log Grate Left

Chateau™

Log Grate Right

LG402

Figure 44

Log Rear	Log Rear Right
Left

pointed end on the matching notch on the overlay toward the right. Rest the wide end toward the back right. The log rests in place by touching the rear refractory lower on the right. (Fig. 44)

9.Position the Log Rear Left

. Position the log rear left by holding the log at an able with the pointed end down toward the bottom. Set the pointed end on the matching notch on the overlay toward the left. Rest the wide end toward the back left. The log rests in place by touching the rear

10. Position the Log Front Left. Posi- tion the log front left by holding the log

with the wide end toward the front and the nar- row end toward the back. Set the rectangular indentation located on the bottom of this log over the rectangular protrusion on the far left end of the log grate left. Lay the pointed end of the log over the burner overlay outside

the log rear left. (Fig. 45)

11.Position the Log Front Middle Left. Position the log front middle left by holding the log with the wide end toward the front and the narrow end toward the back. Set the round indentation located on the bottom of this log over the round protrusion

on the rear left log. Set the log over the fettle where the V-shaped end on the front

of this log (split area) comes in contact with the second left tine on the fettle. (Fig. 45)

Log Front Left

Log Front

Middle Left

	LG405	refractory lower on the left.
	LG405	(Fig. 44)
		(Fig. 44)
		Log Front Right

LG404

Log Front Middle

Right (DVT44)

20011956

29

Image 29

Contents Model: DVT38IN, DVT44IN Installation Instructions and Homeowner’s ManualINSTALLER/CONSUMER SAFETY INFORMATION Chateau20011956 Table of ContentsChateau Chateau Installation & Operating InstructionsDVT38IN / DVT44IN Certiﬁed To 20011956Fireplace Dimensions - DVT44IN Fireplace Dimensions - DVT38INChateau 20011956Locating Your Fireplace ChateauClearance to Combustibles MantelsFraming and Finishing HearthFinal Finishing ChateauGas Speciﬁcations Gas Line InstallationGas Inlet and Manifold Pressures High ElevationsElectrical Junction Box Control System InstallationControl System Chateau20011956 Special Feature for Cold ClimatesChateau ON H/L Remote Control Transmitter Operating InstructionsMODE ChateauSetting Desired Room Temperature Setting F / C ScaleChateau Manual FunctionCP CHILDPROOF FEATURE CONTINUOUS PILOT FEATURESETTING “LOCK-OUT”- CP ChateauChateau Thermostatic Updating FeatureOperational Notes 20011956Chateau General VentingLocation of Vent Termination 20011956US Installations2 Canadian Installations1Chateau 18” 458 mm for non-vinylsofﬁts20011956 ChateauTermination Clearances SK8 Venting Pipes General Information Assembling Vent PipesHorizontal Termination Vertical TerminationUse of the Restrictor Plates in Sidewall ApplicationsHorizontal Venting Applications ChateauChateau Sidewall InstallationSTEP STEP20011956 ChateauSTEP Use of Restrictor Plate Vertical Through-the-Roof Applicationsfor Vertical Venting Applications Chateau20011956 Vertical Through-the-RoofInstallationChateau Ceiling Installation Attic InstallationChateau Min 2 610mmChateau Chimney ComponentsComponent DescriptionGlass Cleaning Glass Frame Assembly RemovalRestrictor Plate Installation Operating InstructionsChateau Ceramic Refractory InstallationAppliance Kit ModelChateau Log, Lava Rock and Ember PlacementDVT38IN Logs 2001195620011956 ChateauDVT44IN Logs 20011956 Chateau9.Position the Log Rear Left 20011956 Chateau12. Position the Log Front Middle Right 20011956 ChateauFig. 48 DVT38IN logset complete Fig. 49 DVT44IN logset completeChateau Flame CharacteristicsDVT38 DVT44Chateau Trim Installation20011956 Fig. 53 Trim frame in placeLighting & Operating Instructions For Your Safety, Read the Following Warningsbefore Lighting the Appliance Lighting InstructionsChateau TroubleshootingAmerican Flame Gas Control System 2001195620011956 ChateauMain ﬂame will not light Chateau American Flame Gas Control System Error CodesWhat to Check What to CheckConversion Procedure Conversion PrecautionsFuel Conversion Instructions Chateau20011956 ChateauConverting the Gas Control Valve Pilot Flame Adjustment Table 2 Air Shutter SettingsTable Injector Oriﬁce Size MatrixCleaning the Control System MaintenanceChateau 20011956For Units GFYN5Q0, GFYN500 DVT38IN, DVT44INChateau 20011956Chateau DVT38IN, DVT44IN continuedDescription DVT38INChateau DVT38IN, DVT44IN continuedDescription DVT38INBack-upBattery Kit AccessoriesCeramic Refractory Kits Chateau20011956 ChateauIF WARRANTY SERVICE IS NEEDED LIMITED LIFETIME WARRANTYLIMITED LIFETIME WARRANTY BASIC ONE-YEARWARRANTYCFM Corporation Efﬁciency Ratings