Windsor QTFSD, QTFSG manual Safety Label Location

Page 7

SAFETY LABEL LOCATION

NOTE: These drawings indicate the location of safety labels on the Tracer FS. If, at any time, the labels become illegible contact your Windsor representative for prompt replacement.

QTFSG/QTFSD 98349 05/15/03	2-3

Image 7

Contents Model Tracer FS Floor SweeperYour Dealer Machine Data LOGOverview Table of Contents Model HOW to USE this ManualRead ALL Instructions Before Using this Machine Important Safety InstructionsHazard Intensity Level Hazard Intensity LevelSafety Label Location Safety Label Location DIMENSION/CAPACITY Technical SpecificationsSpecial Notes ControlsControls Parking Brake Lever Filter Shaker SwitchDirectional Control Pedal Brake PedalEngine Temperature Light Hopper Door SwitchHopper Lift Switch Hopper Safety ARMHorn PAD KEY SwitchChoke GAS only Circuit BreakersTo Sweep OperationsBefore Operating the FS Starting the MachineDumping the Hopper To Engage the Hopper Safety ARMStopping the Machine Storing the MachineTo Jack UP Machine To Disengage the Hopper Safety ARMTowing or Pushing Machine Machine JackingHydraulic Pump MaintenanceHydraulic Fluid Hydraulic Fluid ReservoirDirectional Control System Hydraulic FilterRefer to the Electrical Control Group in the Parts section To Remove the Main Broom To Install the Main BroomMain Broom Adjustment Knob Checking and Adjusting the Main Broom PatternMain Broom Pattern To 1-1/2 25.4 to 38.1mm To Remove the Side Broom To Install the Side BroomAdjusting the Side Broom Raised hopper may fall. Engage hopper safety armTransmission Belt Adjusting the Jackshaft BeltTransmission Jackshaft Belt To Replace BeltReplacing and Adjusting the Vacuum Impeller Belt Replacing and Adjusting Main Broom BeltTo Align Belt Drive Chain Replacing and Adjusting DifferentialImpeller Belt To RealignAdjusting the Right Broom Door Skirt Replacing and Adjusting the Drive Wheel ChainsReplacing the Right Broom Door Skirt Recirculation Skirt Adjusting the Left Broom SkirtAdjusting the Rear Broom Skirt Replacing the Left Broom SkirtHopper LIP Skirts Adjusting the Hopper Side SealsHopper Seals Replacing the Hopper SealsHopper Dust Filter Hopper Door SealsReplacing Door Seals HopperBrakes Refer to the Brake Group in the Parts section To Adjust the BrakesRaised hopper arm may fall. Engage hopper safety arm AIRBattery Maintenance BatteryHopper will not lower Hydraulic Schematic Hydraulic TroubleshootingProblem Cause Solution Hopper will not liftFull speed only No propellingMachine moves without Pressing foot pedalMachine travels slowly Machine TroubleshootingExcessive dusting Poor sweepingMaintenance Daily Weekly 50HRS Service Schedule