Burnham manual Ledv Series, 81433101R16-1/10 Price $3.00

Page 1

INSTALLATION, OPERATING AND SERVICE INSTRUCTIONS FOR

LE®DV SERIES

DIRECT VENT

OIL - FIRED BOILER

As an ENERGY STAR® Partner, Burnham Hydronics has determined that the LEDV1, fired at the 0.60 GPH rate, meets the ENERGY STAR guidelines for Energy efficiency established by the United States Environmental Pro- tection Agency (EPA).

For service or repairs to boiler, call your heating contractor. When seeking information on boiler, provide Boiler Model Number and Serial Number as shown on Rating Label.

Boiler Model Number	Boiler Serial Number	Installation Date
LEDV

Heating Contractor		Phone Number

Address

81433101R16-1/10

Price - $3.00

Image 1

Contents 81433101R16-1/10 Price $3.00 Ledv SeriesImportant Information Read Carefully Page Table of Contents Water Content 6.1 gallons Pre-Installation Do not drop boiler. Do not bump boiler jacket II. Unpack BoilerAgainst floor Minimum Clearances to Combustible Materials III. Water Piping and Trim Page Page General Guidelines IV. Venting / Air Intake PipingIntake Terminal Location Vent Pipe Part NumbersVent Installation Vent Connector, Assembled Air Intake Installation Direct Vent only See Figure Page Electrical Electrical and Sequence of OperationsSequence of Operations Beckett Burner Schematic Wiring Diagram Page General VI. Oil PipingSingle-pipe Oil Lines Two-Pipe Oil Lines Two-Pipe InstallationAdjusting Settings Always Inspect Installation Before Starting BurnerVII. System Start-up Ii. DisplayLED Error Codes Control Operating CharacteristicsBurner START-UP Install Pressure Gauge Riello BF Burner SettingsCheck / Adjust OIL Pressure Remove Test Plug in Flue CollarHints on Combustion Test Controls Simulate power failureSimulate flame failure Simulate ignition failurePage Firetubes and Combustion Chamber Section Viii Service and CleaningBurner Low water cutoff if so equipped Avoid Breathing Fiber Particulates and Dust Ledv Boiler Trim & Controls IX. Repair PartsLedv Boiler Jacket & Insulation Ledv Bare Boiler Assembly PartsRepair KitVent Beckett Afii Oil Burner Repair Part Beckett Afii Burner Replacement Parts Service Record Low Water Cut Off Lwco on Hot Water Boilers Wiring of Typical LwcoLwco Location Limited Warranty