Burnham 81433101R16-1/10 manual

Page 11

Figure 6: Recommended Piping for Combination Heating &

Cooling (Refrigeration) Systems

Figure 7: Recommended Water Piping for Circulator Zoned Heating Systems

11

Image 11

Contents 81433101R16-1/10 Price $3.00 Ledv SeriesImportant Information Read Carefully Page Table of Contents Water Content 6.1 gallons Pre-Installation Against floor II. Unpack BoilerDo not drop boiler. Do not bump boiler jacket Minimum Clearances to Combustible Materials III. Water Piping and Trim Page Page General Guidelines IV. Venting / Air Intake PipingIntake Terminal Location Vent Pipe Part NumbersVent Installation Vent Connector, Assembled Air Intake Installation Direct Vent only See Figure Page Sequence of Operations Electrical and Sequence of OperationsElectrical Beckett Burner Schematic Wiring Diagram Page Single-pipe Oil Lines VI. Oil PipingGeneral Two-Pipe Oil Lines Two-Pipe InstallationIi. Display Always Inspect Installation Before Starting BurnerAdjusting Settings VII. System Start-upBurner START-UP Control Operating CharacteristicsLED Error Codes Remove Test Plug in Flue Collar Riello BF Burner SettingsInstall Pressure Gauge Check / Adjust OIL PressureHints on Combustion Simulate ignition failure Simulate power failureTest Controls Simulate flame failurePage Burner Section Viii Service and CleaningFiretubes and Combustion Chamber Low water cutoff if so equipped Avoid Breathing Fiber Particulates and Dust Ledv Boiler Trim & Controls IX. Repair PartsLedv Boiler Jacket & Insulation Ledv Bare Boiler Assembly PartsRepair KitVent Beckett Afii Oil Burner Repair Part Beckett Afii Burner Replacement Parts Service Record Lwco Location Wiring of Typical LwcoLow Water Cut Off Lwco on Hot Water Boilers Limited Warranty