Hearth and Home Technologies 31ST-ACC, 31M-ACC-MBK Wood Stove Series ACC Typical Stove Systems

Page 8

3100 Wood Stove Series (ACC)

R

H. Typical Stove Systems

Stove system with masonry chimney consists of:

•Stove

•Chimney Connector (stove pipe)

•Thimble

•Masonry Chimney

•Hearth Pad Floor Protection

Spark Arrestor Cap

	Concrete Cap	Fireclay Flue Liner
	Concrete Cap	With Air Space
		With Air Space
	Rafter
		Flashing
	1" (25mm) Clearance
	With Firestop
	Ceiling Joist	Eave
		Eave
	Combustible Wall
	Thimble,
	12" (305mm)
	Of Brick	Sheathing
		Sheathing
		Outside Air Rear Vent
	Floor	Outside Air
	Floor	Termination Cap
	Protector	Termination Cap
	Protector
		Airtight
		Cleanout Door

Figure 8.1 Masonry Chimney

Stove system with prefabricated metal chimney consists of:

•Stove

•Chimney Connector (stove pipe)

•Thimble (for exterior chimney)

•Firestops

•Insulations Shields

•Storm Collar and Flashing

•Termination Cap

•Hearth Pad Floor Protec- tion

Listed Termination Cap

Roof Brace (if required)

Storm Collar

		Flashing
	Trim Collar on	Listed Chimney
	Inside Wall	Insulated "T "
		Insulated "T "
	Chimney	Wall Support
	Connector	Wall Support
	Connector
		Thimble
	Floor
	Protector

Listed Termination Cap

Storm Collar

Flashing

Listed Chimney

Ceiling Support

Chimney

Connector

Floor

Protector

Figure 8.2 Exterior Prefabricated Chimney

Figure 8.3 Interior Prefabricated Chimney

Page

7033-277F

September 1, 2008

Image 8

Contents Step Top Uni-Body Model Millennium Model Hot glass will cause burns7033-277F September 1Wood Stove Series ACC 007Serial No Model Name Mfg. Date 7033-277F September 1Table of Contents Appliance Certification BTU & Efficiency Specifications Glass SpecificationsListing and Code Approvals Mobile Home ApprovedFire Safety Getting StartedWood Stove Series ACC Negative Pressure 7033-277F September 1Wood Stove Series ACC Flue Draft Considerations Venting SystemsTools And Supplies Needed Inspect Appliance & Components and Pre-Use Check ListWood Stove Series ACC Typical Stove Systems Masonry ChimneyMillennium Model Dimensions and ClearancesAppliance Dimensions 10-/8 in mm 21-1/8 in 7mm 7033-277F September 1 11/16 in mm11/16 in mm 89mm Back of Stove to Glass Wood Stove Series ACC Clearances to Combustibles UL and ULC Double Wall PipeInstallation 31004Wood Stove Series ACCHearth Protection Requirements Millennium ModelWood Stove Series ACC Step-Top Uni-Body Model Fire Risk Asphyxiation Risk Wood Stove Series ACC Outside Air Kit InstallationItems Needed for Installation not supplied Wood Stove Series ACC Blower Optional Shock RiskChimney Connector Chimney RequirementsVenting Components Chimney Systems ThimbleComponents Air ClearancesInstructions Solid Pack Chimney with Metal Supports as a ThimbleChimney Height / Rise and Run Installing Chimney ComponentsSolid Pack Chimney with Metal Supports as a Thimble Cont’d Wood Stove Series ACC Chimney Termination Requirements RulePitched Roof Flat RoofMobile Home Installation Appliance Set Up Begin installing the ARS SystemInstalling Pedestal Assembly Finishing the ARS InstallationInstalling Leg Kit Corners. FigureWood Stove Series ACC Door Handle Assembly Adjusting The Blower Speed ControlOperating Instructions Over-Firing Your Appliance Wood Selection & Storage Cont’dWood Selection & Storage Burning ProcessAutomatic Combustion Control ACC Air ControlsBurn Rates and Operating Efficiency Wood Stove Series ACC Building a Fire Wood Stove Series ACC Correct Baffle & Blanket Placement Incorrect PositionsFrequently Asked Questions Opacity Smoke Initial cold start-up and all Burn SettingsWood Stove Series ACC Blower Operating Instructions Snap Disc LocationGeneral Maintenance Ash Removal System ARS Operating and CleaningCreosote Chimney Cleaning Maintaining & Servicing Your ApplianceGlass Cleaning Frequency As desired Cleaning Plated SurfacesWhen cleaning glass Disposal of AshesWood Stove Series ACC Glass Replacement Wood Stove Series ACC Firebrick Replacement Appliance without firebrickTo your authorized dealer Brick Size QtyWood Stove Series ACC Baffle Removal Snap Disc Replacement Snap Disc LocationReplacing Tube Channel Assembly Wood Stove Series ACC Tube Channel Assembly ReplacementRemoving Tube Channel Assembly Troubleshooting Start Fire Problems Possible Cause SolutionReference Materials Exploded view#33 Baffle Board 2 w x 13-3/4 h, each #29 Ceramic Blanket 19 w x 13-3/4 h, 1/2 thickStep-Top Uni-Body Model Flue Collar can’t replace in the fieldWood Stove Series ACC Service Parts & Accessories Blower AssemblyItem # Service Parts Item # Service Parts Wood Stove Series ACC Service And Maintenance Log Date of Service Performed By Description of ServiceWood Stove Series ACC Homeowner’s Notes CONDITIONS, Exclusions & Limitation of Liability September 1 7033-277F Contact Information