Falcon U108610-07 Conversion to LP Gas, Classic - Removing the Control Panel, 3

Page 28

8. Conversion to LP Gas

8. Conversion to LP Gas

Fig.8-1

B

A

ArtNo.311-0010 Injectors	C

A – Jet, B – Internal injector, C – External injector

Fig.8-2

Art No 215-0028 - Handrail fascia fixings

Fig.8-3

.0102-0001 - Unscrewing screw

Conversion from Natural Gas (1.0 kPa) to LPG X Propane (2.75 kPa)

nnA suitably competent person must perform the conversion. After conversion the installation must comply with the relevant regulations and also the local electricity supply company requirements. Read the instructions before converting this appliance.

Failure to convert the appliance correctly could

nn

invalidate any warranty or liability claims and lead to prosecution.

When servicing or replacing gas-carrying

nn

components disconnect from the gas supply before starting operation. Check the appliance is gas sound after completion.

DO NOT use reconditioned or unauthorised gas

nn

controls.

Disconnect from the electricity and gas supply

nn

before servicing.

Before electrical reconnection, check that the

nn

appliance is electrically safe.

Injectors

Remove the burner caps and heads. Remove the old jets (Fig.8-1). Fit the new jets (see the ‘Technical Data’ section at the back of this book for the correct jets). Reassemble in reverse order.

Tap Adjustment

Classic – Removing the Control Panel

Remove the handrail. Now remove the 2 cross-headed screws hidden behind the handrail end brackets (Fig.8-2).

Pull o all the control knobs and remove the xing screws underneath the control panel.

Lift the control panel and pull forwards, taking care not to damage or strain the wiring.

Toledo – Removing the Control Panel

Pull o all the control knobs and remove the xing screws underneath the control panel.

Slide the control panel to the right and then pull forwards, taking care not to damage or strain the wiring.

Replacing the Tap Bypass Screws

Unscrew the tap bypass screw (Fig.8-3)and, using a pair of long nosed pliers, remove. Fit the correct replacement screw (see the ‘Technical Data’ section for details) and tighten down.

Ret the control panel.

26

Image 28

Contents Installation Instructions User Guide90 Dual Fuel U108610-07Contents 1. Before You Start WARNING The appliance and its accessible partssurfaces To avoid overheating, DO NOT install the cooker nnDO NOT use a steam cleaner to clean the cookernnThis appliance is heavy so take care when moving it Always keep combustible materials, e.g. curtainsand ammable liquids a safe distance away from your cooker DO NOT store ammable materials in the storage2. Cooker Overview Hotplate BurnersA B C D Fig.2-1Wok Burner Fig.2-3 Fig.2-4Fig.2-5 Fig.2-6 Fig.2-7DO NOT put it crossways - it will not t properly and will be unstable DO NOT put it on any other burner - it is notdesigned to t in any of the other pan supports Fig.2-12 Always leave space around the griddle for the gasesnnNever close the grill door when the grill is on ArtNo.210-0001 Classic grill controlFig.2-15 Fig.2-16Setting the Time of Day A B C D E FMinute Minder To Stop the Ovens AutomaticallyAUTO is Showing, But you Want to Reset to Manual Cooking Key LockFig.2-30Fig.2-31 Fig.2-32Oven Shelves - Left-hand Main Oven Oven Shelves - Right-hand Tall OvenThe Handyrack Main Oven Fig.2-35Tips on Cooking with the Timer General Oven TipsDO NOT use the timed oven if the adjoining oven is already warm4. Cooking Table 5. Cleaning Your Cooker DO NOT mix dierent cleaning products - they mayThe Single Ring Burners The Wok Burner‘Cook & Clean’ Panels Before you remove any of the grill parts for cleaningDO NOT use harsh abrasive cleaners or sharp metal Do not use steel wool, oven cleaning pads, or anyRecommended Cleaning Method Removing the Main Oven LiningsHotplate Part6. Troubleshooting Hotplate ignition or hotplate burners faultyWhat cleaning materials are recommended for the cooker? Never use caustic or abrasive cleaners as these willFig.6-1 Fig.6-2 Fig.6-3Fig.6-4 An oven light is not working7. Installation If you Have a ProblemOut of Warranty INSTALLATIONInstaller’s Name Installer’s Company Installer’s Telephone Number Read the instructions before installing or using this applianceAS 5601 - ‘Gas Installations’ Failure to install the appliance correctly couldYou will also need the following tools Checking the Parts1. Overhead - Measurement A 2. Side Clearances - Measurements B & C3. Side Clearances - Measurement D & E Fig.7-1Lowering the Two Rear Rollers Completing the MoveOn no account try and move the cooker while it is plugged into the electricity supplyUnless properly installed, the cooker could be tipped by Fitting the Stability Bracket and ChainFitting a Stability Bracket Fitting the Restraining ChainPressure Testing Gas ConnectionNatural Gas PropaneFixed Wiring A NFig.7-10 Fig.7-11Hotplate Check Grill CheckOven Check Fitting the Handles and Handrail Classic only8. Conversion to LP Gas When servicing or replacing gas-carryingClassic - Removing the Control Panel Toledo - Removing the Control PanelFig.8-4 9. Servicing 1.1 To Remove the Control Panel1.2 To Remove the Side Panels WARNING - SERVICING TO BE CARRIED OUT ONLY BY AN AUTHORISED PERSON2.1 To Remove the Hotplate 2.2 To Replace the Hotplate Control Taps2.3 To Change a Hotplate Burner Injector 2.4 To Replace a Hotplate Burner Electrode3.1. To Replace the Ignition or Light Switch 3.2 To Replace the Clock3.3 To Change the Ignition Generator 4.1 To Replace the Grill Controller5.3 To Change the Oven Element 5.4 To Change an Oven Element Thermal Cut-out5.5 To Replace an Oven Thermostat Fig.9-4 Fig.9-56.3 To Adjust the Main Oven Door Angle 6.6 To Adjust the Main Oven Door Catch Keep6.1 To Remove the Grill Door 6.2 To Replace the Main Oven Door6.7 To Remove the Tall Oven Door 6.8 To Replace the Tall Oven Door Outer Panel6.9 To Replace the Tall Oven Door Magnetic Latch 6.10 To Change an Oven Door SealDescription 10. Circuit DiagramColour 11. Technical Data Maximum power output @ 230V 50 HzUsable volume litres COUNTRY OF DESTINATION AustraliaPage Page Tel +44 0 1926 457400 Fax +44 0 1926 Clarence Street, Royal Leamington Spa Warwickshire, CV31 2AD, EnglandE-mail consumers@falconappliances.co.uk