Hoshizaki HWR68A(-D) Freezers Energy Saving Operating Mode, Board Self Check Minute Delay

Page 19

4. Freezers – Energy Saving Operating Mode

a) Sequence of Operation

	POWER ON



Board Self Check						2-minute Delay
1.	Frame heater(s) on					1.	Compressor start-up
1.	Frame heater(s) on					1.	Compressor start-up
2.	Evaporator fan(s)					2.	Condenser fan start-up
	cycles on and off					3.	Evaporator fan(s) on
							(continuously)

Cycle Off (Cut-out temperature reached) [Minimum 2 minutes]

1.Compressor off

2.Condenser fan off

3.Evaporator fan(s) cycles on and off

Cycle On (Cut-on temperature reached) [Minimum 2 minutes]

1.Compressor start-up

2.Condenser fan start-up

3.Evaporator fan(s) on (continuously)

Continue as normal cycling

Defrost Start Preprogrammed time interval

1.Compressor off

2.Evaporator fan(s) off

3.Condenser fan off

4.Defrost heater on

5. "dF" displayed

Defrost End Defrost thermistor reaches defrost termination temperature,

or defrost timer reaches 1 hour

Defrost heater off

Five minutes after defrost heater off

1.Compressor on

2.Condenser fan on

Five minutes after			Eight minutes after evaporator
compressor start-up			fan start-up "dF" no longer
compressor start-up			fan start-up "dF" no longer
1. Evaporator fan(s) on			displayed, cabinet temperature
			displayed
			displayed

Note:

1)Cut-on, cut-off, and cabinet temperature are read by the same sensor, called the "cabinet thermistor."

2)The defrost thermistor reads the evaporator temperature.

19

Image 19

Contents Superior Degree Reliability Energy Star Contents Page Dimensions Specifications Nameplate RatingsUndercounter Model Names HUR40A, HUF40A Units mm 1a. HUR40A-D, HUF40A-D 2a. HWR40A-D, HWF40A-D HWR40A, HWF40A3a. HUR68A-D, HUF68A-D HUR68A, HUF68A4a. HWR68A-D, HWF68A-D HWR68A, HWF68AHUR96A Units mm 5a. HUR96A-D HWR96A Units mm 6a. HWR96A-D Evaporator Case II. General Information ConstructionRefrigerators Continuous Operating Mode Sequence of Operation and Timing ChartsSequence of Operation Operating Timing ChartFreezers Continuous Operating Mode Freezers Continuous Defrost End Defrost thermistor reaches defrost Refrigerators Energy Saving Operating ModeEnergy Board Self Check Minute Delay Freezers Energy Saving Operating ModeFreezers Energy Control Board Start-Up DelayFront Relay Wiring Harness K311Thermistor Wiring Harness K151 RearGaining Access to Settings and Diagnostics Settings and DiagnosticsSwitching the Display Between Fahrenheit and Celsius F5 Temperature DisplayAdjusting the Setpoint Temperature Cabinet Temperature Correction calibration factor Later Section Settings and Diagnostics MenuDefrost Interval F0 Defrost Termination Temperature F1Setpoint Temperature Differential F2 Low Temperature Alarm Delay Time F4 High Temperature Alarm Delay Time F3Alarm History F6 Temperature Display Scale F5Operating Modes Compressor Run Time F7Continuous Perimeter Frame HeaterEnergy Saving Alarm Signals Alarm Code Problem III. Service Diagnosis Alarm CodesError Code Priority Description Alarm Display PriorityPossible Causes Alarm Details and CountermeasuresHigh Temperature Alarm E1 Reset OptionsLow Temperature Alarm E2 High Pressure Alarm E4 Defrost Alarm E3Clogged Filter Alarm E7 Defrost Temperature Sensor Malfunction Alarm E8 Clogged Filter Sensor Malfunction Alarm E9 Control Board Error Alarms EA and ED Problem Possible Cause Remedy Diagnosis ChartProblem Possible Cause Remedy Problem Possible Cause Remedy Thermistor Check Brazing IV. Removal and Replacement of ComponentsService for Refrigerant Lines Refrigerant RecoveryEvacuation and Recharge Removal and Replacement of Compressor Removal and Replacement of Refrigeration UnitRemoval and Replacement of Evaporator Page Page Clogged Filter Thermistor sensor Removal and Replacement of ThermistorsCabinet Thermistor Defrost ThermistorRemoval and Replacement of Defrost Heater Removal and Replacement of Door GasketRemoval and Replacement of Control Board Evaporator Fan Motor Removal and Replacement of Fan MotorsDoor Re-Hinging and Drawer Conversion Condenser Fan MotorCleaning Cleaning and Maintenance InstructionsDrawers MaintenanceAir Filter Shelves115/60/1 A2. HUR40A-D, HWR40A-D auxiliary code Q6 and later HUF40A-D, HWF40A-D C1. HUR68A, HWR68A auxiliary code Q5 and earlier C2. HUR68A-D, HWR68A-D auxiliary code Q6 and later HUF68A-D, HWF68A-D HUR96A-D, HWR96A-D