Multiquip DCA125USI3CAN Trailer Maintenance, Coupler Type of hitch used on the trailer for towing

Page 41

Trailer Maintenance

Trailer Maintenance

This section is intended to provide the user with generic trailer service and maintenance information. The service and maintenance guidelines referenced in this section refer to a wide range of trailers.

Remember periodic inspection of the trailer will ensure safe towing of the generator and will prevent personal injury and damage to the equipment.

The definitions below describe some of the major components of a typical trailer that would be used with generator.

1.Fuel Cell — Provides an adequate amount of fuel for the equipment in use. Fuel cells must be empty when transporting equipment.

2.Braking System — System employed in stopping the trailer. Typical braking systems are electric, surge, hydraulic, hydraulic-surge and air.

3.GVWR — Gross Vehicle Weight Rating (GVWR) is the maximum number of pounds the trailer can carry, including the fuel cell (empty).

4.Frame Length — Measurement is from the ball hitch to the rear bumper (reflector).

5.Frame Width — Measurement is from fender to fender

6.Jack Stand — Trailer support device with maximum pound requirement from the tongue of the trailer.

7.Coupler — Type of hitch used on the trailer for towing.

8.Tire Size — Indicates the diameter of the tire in inches (10,12,14, etc.), and the width in millimeters (175,185,205, etc.). The tire diameter must match the diameter of the tire rim.

9.Tire Ply — The tire ply (layers) number is rated in letters; 2-ply, 4-ply, 6-ply, etc.

10.Wheel Hub — The wheel hub is connected to the trailer’s axle.

11.Tire Rim — Tires mounted on a tire rim. The tire rim must match the size of the tire.

12.Lug Nuts — Used to secure the wheel to the wheel hub. Always use a torque wrench to tighten down the lug nuts. See Table 18 and Figure 63 for lug nut tightening and sequence.

13.Axle — Indicates the maximum weight the axle can support in pounds, and the diameter of the axle expressed in inches. Please note that some trailers have a double axle. This will be shown as 2-6000 lbs., meaning two axles with a total weight capacity of 6000 pounds.

14.Suspension — Protects the trailer chassis from shocks transmitted through the wheels. Types of suspension used are leaf, Q-flex, and air ride.

15.Electrical — Electrical connectors (looms) are provided with the trailer so the brake lights and turn signals can be connected to the towing vehicle.

16.Application — Indicates which units can be employed on a particular trailer.

DCA125USI3CAN 60 hz Generator • operation and parts manual — rev. #2 (09/24/13) — page 41

Image 41
Contents Model DCA125USI3CAN Parts List NO. M3874400004Fuel and chemical warnings Nhtsa Reporting Safety DefectsAdministrator DCA125USI3CAN Generator Table of ContentsChoose from three easy options SaFetY SYmBolS Safety InformationSaFetY meSSageS Generator Safety GeNeral SaFetYIf operating in speed ranges above the maximum allowable ENGiNE SafetyRestricted. If the air fl ow is TOWiNG Safety FUel SaFetY„ Never use fuel as a cleaning agent From fuel vapors or if fuel is spilled on a hot engineGrounding Safety EleCtrICal SaFetYPower Cord/Cable Safety DeathENvIroNmeNtal SaFetY BatterY SaFetYModel Isuzu 4HK1XYGD-03 Tier SpecificationsDimensions DimensionsTypical Generator Grounding Application InstallationIndoor Installation Outdoor InstallationMounting Generator GroundingGeneral Information Major Components Generator Control Panel Generator Control PanelPage Engine Operating Panel Module Fuel Gauge Indicates amount of diesel fuel availableOutput Terminal Panel is provided with the following Output Terminal FamiliarizationTerminal legs O and Ground are considered bonded grounds Twist Lock Dual Voltage 120/240 VAC Receptacles Removing the Plastic Face Plate Hard Wire Hookup PanelVAC Gfci Receptacles Over Current Relay Connecting LoadsThree Phase Load Single Phase LoadLoad Application Type of LoadVoltage Selector Switch Locking Button Voltage Selector SwitchGenerator Output Voltages Generator AmperageGenerator OUTPUTS/gauge reading How to Read the ac ammeter and ac voltage gaugesAC Voltmeter Gauge Reading AC Ammeter Gauge Reading3Ø-208V/1Ø-120V Uvwo Terminal Output Voltages Uvwo Terminal Output Voltages3Ø-240/139 Uvwo Terminal Output Voltages 1Ø-240/120V Uvwo Terminal Output Voltages 3Ø-480/277V Uvwo Terminal Output VoltagesCircuit Breakers Inspection/SETUPLubrication Oil Fuel CheckOnly use #2 diesel fuel when refueling Refueling ProcedureAir Cleaner Fan Belt Tension Cleaning the RadiatorCoolant Antifreeze/Summer Coolant/ Water Operation in Freezing WeatherBattery Cable Installation BatteryWiring AlternatorBefore Starting Place the engine speed switch in the LOW down positionStarting Starting ManualPre-Heat Lamp Emergency Shutdown Procedure Normal Shutdown ProcedureTo shutdown the generator, use the following procedure OFF/RESET positionAir Cleaner with Dust Indicator MaintenanceGeneral Inspection Air Cleaner Air Removal Fuel AdditionFuel Tank Inspection Check Oil Level Radiator CleaningReplacing Oil Filter Flushing Out Radiator and Replacing CoolantBattery Charger & Jacket Water Heater Power Connections Coupler Type of hitch used on the trailer for towing Trailer MaintenanceTrailer Maintenance Brakes Brake AdjustmentHydraulic Surge Brakes ActuatorSuspension Tires/Wheels/Lug NutsTire Wear/Inflation Never use an pneumatic air gun to tighten wheel lug nuts Lug Nut Torque RequirementsStart all wheel lug nuts by hand Trailer/Towing Vehicle Wiring Diagram Trailer Wiring DiagramGenerator Wiring Diagram Generator Wiring DiagramEngine Wiring Diagram Engine Wiring DiagramController Wiring Diagram Controller Wiring DiagramSymptom Possible Problem Solution Troubleshooting GeneratorMethod of Operation Troubleshooting Diagnostic lampPage Explanation of Code in Remarks Column Qty Description Suggested Spare PartsTo 3 units Generator Assy Field Assy Part Name QTY. RemarksFAN Coupling DiskControl box Assy Diagnostic Switch Push Button SwitchSelector Switch Part Name QTY RemarksControl box Assy Switch Cover Switch BracketAlarm Lamp Water Temperature GaugeControl box Assy Wire HARNESS, Engine SWITCH, Fuel PumpEngine and Radiator Assy INDICATOR, AIR Cleaner AIR CleanerBracket AIR Cleaner BAND, AIR CleanerEngine and Radiator Assy AIR Duct Hose ConnectorBlow by Hose Hose JointEngine and Radiator Assy Cooler Hose BRACKET, Inter CoolerFAN Shroud BRACKET, FAN ShroudOutput Terminal Assy Output Terminal Bolt Terminal BoardTerminal Cover Output WindowBattery Assy Battery Sheet BatteryBattery Band Battery Bolt SETMuffler Assy Exhaust Pipe MufflerGasket Bolt SETFuel Tank Assy Fuel Tank CAP Fuel TankFuel Sender Unit Fuel Tank BracketEnclosure ASSY. Part Environmental Tank BaseFront Frame Hose CoverEnclosure ASSY. Part Duct Back PlateOver COVER, Front Frame COVER, Radiator CAPEnclosure ASSY. Part Rear Frame Enclosure ASSY. Part Washer Seal RubberManual Pack Side PanelRubber Seals Assy REMArks Nameplate and Decals Assy Decal Decal NOTICE, Load Sharing FrenchNameplate and Decals Assy Plate MQ Power Decal MQ PowerDecal NOTICE, Supply Wires English Decal NOTICE, Supply Wires FrenchFreIght polICY Terms and Conditions of Sale PartsPage HERE’S HOW to GET Help