Multiquip SG1400C3-55748 manual BaTTerY SaFeTY, EnvironmenTal SaFeTY

Page 11

Safety Information

BaTTerY SaFeTY

danger

„do noT drop the battery. There is a possibility that the battery will explode.

„do noT expose the battery to open fl ames, sparks, cigarettes, etc.The battery contains combustible gases and liquids. If these

gases and liquids come into contact with a fl ame or spark, an explosion could occur.

Warning

„ alWaYS wear safety glasses when handling the battery to avoid eye irritation.The battery contains acids that can cause injury to the eyes and skin.

„Use well-insulated gloves when picking up the battery.

„alWaYS keep the battery charged. If the battery is not charged, combustible gas will build up.

„alWaYS recharge the battery in a well-ventilated environment to avoid the risk of a dangerous concentration of combustible gasses.

„If the battery liquid (dilute sulfuric acid) comes into contact with clothing or skin, rinse skin or clothing immediately with plenty of water.

„If the battery liquid (dilute sulfuric acid) comes into contact with eyes, rinse eyes immediately with plenty of water and contact the nearest doctor or hospital to seek medical attention.

CauTion

„alWaYS disconnect the negaTive battery terminal before performing service on the generator.

„alWaYS keep battery cables in good working condition. Repair or replace all worn cables.

environmenTal SaFeTY

NOTICE

„Dispose of hazardous waste properly. Examples of potentially hazardous waste are used motor oil, fuel and fuel fi lters.

„do noT use food or plastic containers to dispose of hazardous waste.

„do noT pour waste, oil or fuel directly onto the ground, down a drain or into any water source.

SG1400c3 studio generator • operation and parts manual — rev. #1 (02/15/12) — page 11

Page 10 Page 12
Image 11
Page 10 Page 12
Contents Model SG1400C3-55748 Proposition 65 warning Nhtsa Reporting Safety DefectsSpecifications are subject to change without notice Table of ContentsChoose from three easy options SaFeTY SYmBolS Safety InformationSaFeTY meSSageS GeneraTor SaFeTY General SaFeTYIf operating in speed ranges above the maximum allowable Engine SaFeTYRestricted. If the air fl ow is From fuel vapors or if fuel is spilled on a hot engine Fuel SaFeTYToWing SaFeTY „ never use fuel as a cleaning agentDeath EleCTriCal SaFeTYGrounding Safety Power Cord/Cable SafetyEnvironmenTal SaFeTY BaTTerY SaFeTYModel Cummins QSB7-G5 SpecificationsDimensions DimensionsTypical Generator Grounding Application InstallationGenerator Grounding Outdoor InstallationIndoor Installation General information Intake Ventilation Door Fuel TankFuel Priming Pump Fuel Water SeparatorInteliVision 5 Digital Controller Page Major Components Generator Major ComponentsDescription Starter Oil Filler CapAlternator Oil FilterLicense Plate Lights Illuminates license plate Basic Trailer ComponentsControl panel Controller Power Switch Provides power to engine controllerCamlok/Voltage Output Panel Camlok/voltage output panelMain Breaker Panel Circuit Breaker panelMCB Control Button Not functional in this application Digital controllerType of Load Single Phase LoadThree Phase Load Load application/generator outputGenerator Amperage Voltage Selector SwitchGenerator Output Voltages Fuel Check Inspection/setupRefueling Procedure Lubrication OilWait for fuel to rise in filler neck Only use #2 diesel fuel when refuelingRemove fuel cap and fill tank Figure Operation in Freezing Weather Cleaning the RadiatorAir Cleaner Fan Belt Tension Drive Belt inspection Coolant Antifreeze/summer coolantAlternator Battery Cable InstallationWiring When connecting the battery do the followingEngine’s exhaust contains harmful emissions Always have adequate ventilation when operatingBefore Starting Starting Manual Engine will go to idle modeStartup Closing the Enclosure DOORs Normal Shutdown ProcedureEmergency Shutdown Procedure Protective devices Protective devicesEngine Maintenance Schedule MaintenanceAir Filter Air Filter Dust IndicatorCleaning Inside the Fuel Tank General InspectionCheck Oil Level Fuel Tank InspectionReplacing Fuel Filter Air RemovalHydraulic Brake Actuator Manually Adjusting the BrakesTrailer Brakes Hydraulic BrakesWheel Bearings Adjustable ChannelLeaf Suspension Wheel Hub AdjustmentTroubleshooting Generator Troubleshooting generatorTroubleshooting Engine Troubleshooting engineTroubleshooting Intelivision 5 Controller Troubleshooting controllerTrailer ToWing guidelineS Trailer guidelinesCommon CauSeS For loSS oF Trailer Coupling To THe ToW veHiCle Driving CondiTionSTrailer vin Tag InoperaBle BraKeS, ligHTS or mirrorSTrailer ToWing TipS BraKe ConTroller EleCTriCal ConneCTorToW veHiCle SuSpenSion SYSTemBreaKaWaY SYSTem SaFeTY CHainSTrailer ligHTing and BraKing ConneCTor EmergenCY FlareS andTriangle reFleCTorSCoupling the Trailer to the Tow vehicle Ball Coupler Lock washer and hitch frameTrailer tongue. Wood or concrete blocks may also be used Breakaway Cable Surge Brake System Attaching Safety ChainBreakaway Brake System Pintle Coupler and pintle Hook Connecting Trailer lightsUncoupling the Ball Hitch PinTle HiTCH CouplerCoupling Trailer to Tow vehicle pintle Coupler Figure H. Attaching Safety Chain Pintle HitchBe sure lug nuts are tight before each tow Tire SaFeTY Unsafe Tires, lug nuts or WheelsDetermining load limit of Trailer Determining load limit of Tow vehicle Step StepLetter rating Speed rating Tire FundamenTalSUniform Tire Quality grading Standards uTQgS Tire Safety TipsTire repair Replacing Worn or damaged TiresLug nut Torque requirements Wheel rimsWheels, Bearings and lug nuts Figure M. Trailer to Tow Vehicle Wiring Diagram Lights and SignalsHydraulic Hoses Schematic Maintenance Parts Locator Generator Wiring Diagram Generator Wiring Diagram Explanation of codes in remarks column Qty Description Suggested spare partsSG1400C3 with Cummins QSB7-G5 Diesel Engine 1 to 3 units Housing Base assy EE33397 EE55742EE40474 BASE, 1400A STUDIO, 48 X EE6653Housing interior assy Door ASSY, Camlok SWITCH, OMRON, Enclosed LimitDoor ASSY, Left Side HANDLE, Door Assy PH110ZN LATCH, Door HANDLE, 2-POINTCAMLOK assy Bates CONN, 100A, 125V, Female PANEL, Output BUS, CamlokBUS BAR, 6 SET CAMLOK, 3 Spacing BUS BAR, Ground to NeutralControl box assy. panel Intelivision 5.7 Display SWITCH, TOGGLE, DPDT, ON/OFF/ONPANEL, INSTR, Intelivision HINGE, Control PNL MTGControl BOX assy. Interior BOX, Intelligen Control SWITCH, 15 MIN. Timer W/ ScrewsBOOT, DEUTCH, DRC26-24 BT BOOT, DEUTCH, DRC26-40 BTENGINE/GENERATOR Mounting assy FITTING, BULKHEAD, Brass 1/4 NPT Drive Disc Assy SAE #11.5Motor MOUNT, Fail SAFE, 840 LBS NUT PLATE, Base AssyRADIATOR/MUFFLER Support Unistrut CHANNEL, MFL Support SUPPORT, RadiatorCOVER, FAN, Steel ASSY, ARC Baffel W/ InsulationRADIATOR/FAN Assy BRACKET, Overflow Bottle WASHER, SAFETY, Hydraulic FANRADIATOR, Alum Overflow BOTTLE, RAD CoolantRadiator piping Mntg Head KIT, Coolant Filter Upper Water LineLower Water Line FILTER, COOLANT, SPIN-ONAIR Filter HOSING/PIPING CIA, TURBO, STYLE, 4 1/2 AIR FILTER, 13 DonaldsonBAND, Metal A/C Mntg Hump HOSE, STR. Rubber 5 IDExhaust assy BOLT, 4 Flat Mounting BAND, 16 RoundSILENCER, 16 Cylindrical TAILPIPE, 5 ExpandedSaddle BOX Assy CAPACITOR, 7.5 MFD DECAL, CAUTION, do not SwitchSWITCH, AUX, ABB REGULATOR, VOLTAGE, DVR2000EEngine starter, relay and batterY Assy RELAY, Starter Solenoid TRAY, BATTERY, 27-60, SSBOLT, BATTERY, 10.38 Long PANEL, Starter RelayFuel System Assy HOSE, BARB, Steel 3/8 FUEL-WATER SEPARATOR, RacorPUMP, FUEL, Stewart Warner PLATE, MTG, Fuel PumpFuel System Assy ADAPTER, EXTENDED, 3/8 X 3/8 Street TEE, 1/2 ThreadCLAMP, HOSE, 3/8 HYD. vent actuator hosing Assy FITTING, STRAIGHT, 3/8MJX3/8MAORB ANGLE, BracketEngine component Assy ACTUATOR, ETR Fuel Control FILTER, FuelAlternator PUMP, FuelHyd. MANIFOLD, Valve and Hose Assy BRACKET, HYD. Actuator Manifold MANIFOLD, HYD. ACTUATORS, 150 PSITest FITTING, Pressure Gauge CONN, DIN, PROPORTIONAL, SolenoidHyd. TANK, Filter and Hose Assy ELEMENT, HYD. Filter Tank ASSY., 7 GAL HYD ResivoirTEE, STREET, 1/2 Nptf Hyd. TANK, Filter and Hose Assy TEE, UNION, 1/2 Nptr ELBOW, 90., Male PipeFlame Resistant USMSHA2G-1C-14C/33 Goodyear Hyd. PUMP, COOLER, FAN Motor and Hose Assy Test FITTING, Pressure Guage SAEJ20R3-HT-D3-EC, GoodyearCrankcase ventilation Assy HEAD, Crankcase Assy CANISTER, Crankcase AssyFILTER, High Density FILTER, Ultra DensityTrailer Assy NUT, HX. NYLOCK-INSERT, GRD PINTLE, EYE, RingCAP SCREW, HX. HD. GRD WASHER, Flat Zinc PLT /8FreigHT poliCY Terms and conditions of sale partsPage HERE’S HOW to GET Help

SG1400C3-55748 specifications

The Multiquip SG1400C3-55748 is an advanced generator designed for a wide array of applications, including construction sites, event management, and emergency power backup. At the heart of this robust unit lies a powerful engine that produces reliable energy output, ensuring that it meets the demands of both professionals and casual users alike.

The SG1400C3-55748 boasts an impressive power rating of 14 kW, making it suitable for powering multiple tools and equipment simultaneously. This generator is equipped with a durable and fuel-efficient engine, capable of running for extended periods without compromising performance. Efficient fuel consumption is a critical feature, allowing users to maximize productivity while minimizing operational costs.

One of the standout features of the SG1400C3-55748 is its advanced sound attenuation system. This generator is designed with a noise-reduced enclosure that significantly lowers operational sound levels, making it an excellent choice for noise-sensitive environments. This feature not only enhances user comfort but also complies with noise regulations that may be in effect at various job sites.

The Multiquip SG1400C3-55748 incorporates advanced technologies, including automatic voltage regulation (AVR), which offers stable power output and protects connected devices from voltage fluctuations. This is particularly beneficial for sensitive electronics and equipment that could be damaged by irregular power supply. The generator also features an easy-to-read control panel that allows users to monitor output levels and operating conditions effortlessly.

Safety is a priority for the SG1400C3-55748, featuring multiple safety mechanisms such as low oil shutdown and over-temperature protection. These features ensure that the generator operates within safe parameters, reducing the risk of damage to the unit and connected loads.

The portability of the Multiquip SG1400C3-55748 is enhanced by its compact design and integrated wheel kit, allowing easy transportation between job sites. Whether for emergency use, outdoor events, or construction, this generator offers the versatility and reliability needed for various applications.

In summary, the Multiquip SG1400C3-55748 is a powerful, efficient, and portable generator. Its advanced technologies, user-friendly features, and safety mechanisms make it an ideal choice for professionals and homeowners alike, ensuring that you have the reliable power you need when you need it most.
Top Page Image Contents