Harrington Hoists TCR owner manual Adjusting the Controls, Cord Control

Page 22

4.3.3Cord Control - When using a hoist with cord control, pull down on the appropriate colored cord to raise or lower the hoist. White indicates the raise control and red indicates lowering control. Release the cords to stop the hoist. Refer to Figure 4-2 below.

	Figure 4-2Cord Control
4.3.4	CAUTION Make sure the motor completely stops before reversing direction.

4.4Adjusting the Controls

4.4.1For pendant control, the speed can be adjusted by the amount the lever is depressed. As shown below in Figure 4-3, by depressing the lever slightly, you will be able control the hoist’s motions slowly and with more precision. By depressing the lever further, the speed of the hoist will be increased until the lever is fully depressed.

4.4.2For the cord type control, adjust the speed by varying the amount of pull on the cord. Refer to Figure 4-4.

Figure 4-4Cord Control Speed Adjustment

22

Image 22

Contents AIR Powered Chain Hoist TCR Series EFFFECTIVEMay1,1,20006Table of Contents Section Important Information and Warnings Terms and SummaryPage Page 1Warning Tag Attached to Air Hoist Pendant Model Cord 1Hoist Specifications SpecificationsTechnical Information Dimensions 4Top and Bottom Hook Dimension Part NamesPage Air Supply Capacity And Regulation Preoperational ProceduresAir Supply System Requirements Lubrication1Diagram of Air Supply Configuration Typical Piping, Hoses And Fittings1Air Supply Pipe and Hose Sizes Mounting Location Connecting Hoist to Air SupplyMounting the Hoist Non-Stationary Application Preoperational Checks and Trial Operation6Capsized Hook and Chain Page Operation IntroductionShall’s and Shall Not’s for Operation Hoist Controls 1Pendant ControlAdjusting the Controls Cord ControlOperation of the Load Limiter General InspectionInspection Classification 1Frequent Inspection Frequent InspectionPeriodic Inspection 2Periodic InspectionInspection Methods and Criteria Occasionally Used HoistsInspection Records 3Hoist Inspection Methods and Criteria ActionSee Sections Suspension housing, chain attachments, clevises Figure No TCR10000C2 TCR10000P2Hoists Parts View Recorded Dimension Maximum/Minimum Value 6Top Hook & Bottom Hook DimensionsFor Replacement Load Chain Lubrication LubricationAir Hoist Lubrication Hooks and Suspension ComponentsMaintenance and Handling Load LimiterBrake Replacement Load Chain3Diagram showing chain replacement Pendant 4Pendant Hose and Strain Relief ConnectionsOutdoor Installation StorageTroubleshooting 1Troubleshooting Guide Symptom Cause Remedy1Troubleshooting Guide Symptom Cause Remedy Warranty Parts Information TCR NameplatePage Page Harrington Hoists, Inc Harrington Hoists Western Division