Guardian Technologies 004701-0 Optional remote Start/stop panel, Before starting the engine

Page 9

Section 2 – Operation

Recreational Vehicle Generator

2.2optional remote

start/stop panel

A remote mounted Start/Stop Panel is available that permits starting and stopping the generator engine conveniently from inside the vehicle.

Contact an Authorized Service Dealer to order, a remote panel that includes a Start/Stop switch, a generator run lamp, a fuel prime switch, and an hourmeter. The hourmeter provides a continuous indication of engine/generator operating time. Use the hourmeter for checking off periodic maintenance requirements on the unit.

2.3Before starting the engine

NOTE:

Instructions and information in this manual assume the generator has been properly installed, connected, serviced, tested and adjusted by a qualified installation technician or installation contractor.

2.3.1 Installation

Generator installation must have been properly com- pleted so it complies with all applicable codes, stan- dards and regulations and with the manufacturer's recommendations.

2.3.2 engine lubrication

Have the engine crankcase properly serviced with the recommended oil before starting. Refer to Section

1.5.4and Sections 3.1 and 3.2 for oil servicing pro- cedures and recommendations.

Any attempt to crank or start the engine before it has been properly serviced with the recom- mended oil may result in an engine failure.

2.3.3 Fuel Supply

The engine must have an adequate supply of proper fuel to operate. Before starting it, check that suffi- cient fuel is available.

2.3.4 Cooling and Ventilating Air

Air inlet and outlet openings in the generator com- partment must be open and unobstructed for con- tinued proper operation. Without sufficient cooling and ventilating airflow, the engine/generator quickly overheats, which causes it to shut down and may damage the generator.

2.3.5 engine exhaust gas

Before starting the generator engine, be sure there is no way for exhaust gases to enter the vehicle interior and endanger people or animals. Close windows, doors and other openings in the vehicle that, if open, might permit exhaust gases to enter the vehicle.

danger

The generator engine releases DEADLY carbon monoxide gas through its exhaust system. This dangerous gas, if breathed in sufficient con- centrations, can cause unconsciousness or even death. Never operate the generator set with the vehicle inside any garage or other enclosed area. DO NOT OPERATE THE GENERATOR IF THE EXHAUST SYSTEM IS LEAKING OR HAS BEEN DAMAGED. SYMPTOMS OF CARBON MONOXIDE POISONING ARE (a) inability to think coher- ently, (b) nausea, (c) vomiting, (d) twitching muscles, (e) throbbing temples, (f) dizziness,

(g) headaches, (h) weakness, and (i) sleepiness.

IF EXPERIENCING ANY OF THESE SYMPTOMS, MOVE INTO FRESH AIR IMMEDIATELY. IF SYMPTOMS PERSIST, GET MEDICAL HELP. Shut down the generator and do not operate it until it has been inspected and repaired.

danger

Never sleep in the vehicle while the genset is running unless the vehicle has a working carbon monoxide detector. The exhaust system must be installed in accordance with the genset installa- tion manual. Make sure there is ample fresh air throughout the RV when operating the genset at all times.

2.4starting the generator

NOTE:

Read the vehicle manufacturer’s instructions. The owner/operator should become familiar with the vehicle in which this generator is installed. Differences exist between vehicles. For example, some vehicles may use a transfer switch to isolate dockside power from the generator, while other vehicles may use an isolating receptacle. Some vehicles may be equipped with a DC converter, which allows the generator to power certain DC lighting and other DC loads.

To start the generator from either the generator con- trol panel or from the optional remote panel, proceed as follows:

1.Turn OFF electrical loads using the means pro- vided in the vehicle (such as a main line circuit breaker or transfer switch).



Page 8 Page 10
Image 9
Page 8 Page 10
Contents Air-cooled Recreational Vehicle Generators Authorized Service IntroductionDealer Location Table of Contents  General Hazards   Electrical Hazards  Model Generator IdentificationSpecifications SafetyGenerator Applicability Generator ac Connection systemGenerator control panel Optional remote Start/stop panel Before starting the engineStarting the generator Stopping the generator Do not overload GeneratorProtection Systems  2.8.3 field boost Additional Information 2.8.4 overvoltage protection  2.9.1 25-HOUR BREAK-IN PeriodChecking the Engine OIL LevelCHANGing the Engine OIL And/or Oil Filter Clean air intake Maintaining The Engine AIR Cleaner 3.3.1 cleaning the Foam Precleaner  3.3.2 cleaning or replacing the paper filterClean spark arrestor Cleaning the GeneratorChecking the Engine Spark Plug Battery Maintenance Out of Service ProcedureExercising the Generator Adjusting Valve Clearance Rv generator service interval 3.11.2 Return To Service Part Installation Instructions  General Hazards   Electrical Hazards   Fire Hazards  Equipment Description Purpose and ScopeGenerator Engine Operating Speed Generator AC Connection SystemView from TOP  2.1.1 Generator Location Location and SupportGenerator Compartments  2.2.1 Compartment Size 2.2.2 Compartment Construction  2.2.4 Acoustics  2.2.3 Sound Insulating MaterialsCooling and Ventilating Air  2.2.5 Compartment Floor Cutouts 2.3.1 Generator airflow LP Gas Fuel System  2.3.2 Testing the Installation 2.4.1 Parts not Included in Fuel System  2.4.2 Some Important Considerations 2.4.4 primary regulator  2.4.3 vapor withdrawal 2.4.5 Gaseous Carburetion  2.4.6 fuel supply linesExhaust System  2.4.8 leakage tests 2.5.1 Spark Arrestor  2.6.2 Wiring  2.5.2 Exhaust System SafetyElectrical Connections  2.6.1 Electrical Junction BOX 2.6.6 Power Supply Cord  2.6.3 Generator AC Connections 2.6.4 Conduit 14 Transfer Switch Isolation Method  2.7.3 Battery Cable Connections Optional Accessories 2.7.4 Battery Compartment  2.8.1 remote start/stop panelTesting Under Load Post Installation TestsBefore Initial START-UP Initial StartInstallation Checklist Problem Cause Correction Troubleshooting GuideAppendix 2 Electrical Data Supplied by Customer 24 7 QTY Description 21 2 ASSEMBLY, Brush Holder 274 Regulator Voltage Appendix 3 Exploded Views and Parts Lists GUARD, FAN Appendix 3 Exploded Views and Parts Lists Long Block Assembly 220 RV LP Recreational Vehicle Generator Regulator Drawing No F5819 CASTING, Twin Regulator Housing Your Warranty Rights and Obligations MANUFACTURER’S Emission Control System Warranty CoveragePURCHASER’S/OWNER’S Warranty Responsibilities Emission Related Parts Include the Following Emission Control System WarrantyWarranty Schedule Consumer/Personal Applications

004701-0 specifications

Guardian Technologies 004701-0 is a state-of-the-art air purifier designed to enhance indoor air quality and create a healthier living environment. This innovative device utilizes advanced technologies to combat airborne pollutants, allergens, and other harmful particles, making it an excellent choice for homes, offices, and other indoor spaces.

One of the standout features of the Guardian Technologies 004701-0 is its powerful True HEPA filtration system. True HEPA filters are capable of capturing 99.97% of particles as small as 0.3 microns, including dust, pollen, smoke, and pet dander. This ensures that the air you breathe is free from common allergens and irritants, promoting overall health and well-being.

In addition to its HEPA filter, the device incorporates a UV-C light technology that works to eliminate harmful bacteria and viruses. This dual-action air purification method not only filters out physical particles but also reduces the presence of microorganisms, further enhancing the air quality in your space. The UV-C light operates effectively without any chemicals, making it a safe and eco-friendly choice.

The Guardian Technologies 004701-0 is designed with user convenience in mind. It features a sleek, compact design that fits seamlessly into any room decor, and it operates quietly, ensuring that it does not disrupt your daily activities or sleep. The device also comes with multiple speed settings, allowing users to adjust the airflow based on their preferences and the size of the room.

Another notable characteristic of this air purifier is its filter replacement indicator. This feature alerts users when it’s time to replace the filter, ensuring that the unit operates at peak performance without any guesswork. The ease of maintenance makes it simple for users to keep the purifier running efficiently.

In conclusion, the Guardian Technologies 004701-0 is a powerful air purifier that combines advanced filtration and sanitization technologies to create a cleaner and healthier indoor environment. With its True HEPA filter, UV-C light, user-friendly design, and convenient features, it stands out as a reliable solution for improving indoor air quality and overall health. Whether you are looking to reduce allergens or simply breathe cleaner air, the Guardian Technologies 004701-0 is a wise investment for any household or workspace.
Top Page Image Contents