User’s Manual
PCA-6359 Series
Full-size Pentium MMX 266 PCI/ISA-bus CPU card
Copyright notice
Acknowledgements
http//support.advantech.com
Optional Devices
Packing List
Also refer to the PCA-6359 Series features elsewhere in this manual
PCA-6359 Series Comparison Table
Chapter 1 Hardware Configuration
Chapter 2 Connecting Peripherals
Contents
Chapter 3 Award BIOS Setup
Chipset Features Setup
PCA-6359VE/F only
Chapter 4 PCI SVGA Setup PCA-6359V/VE/F only
Chapter 6 SCSI Setup and Configurations
Chapter 5 PCI Bus Ethernet Interface
Appendix B Pin Assignments
Appendix A Programming the Watchdog Timer
Appendix C DiskOnChip 2000 Installation Guide
Appendix D LCD Services
CHAPTER
Hardware Configuration
Guaranteed long product supply time
1.1 Introduction
Embedded Pentium MMX CPU
Chapter 1 Hardware Configuration
1.2 Features
6. More
1.3 Specifications
Standard SBC functions
VGA function PCA-6359V/VE/F only
I/O address switchless setting Connector type RJ-45
Mechanical and environmental specifications
Ethernet controller functions PCA-6359VE/F only
SCSI function PCA-6359F only
Figure 1-1 PCA-6359 Series board layout dimensions
1.4 Board Layout Main Features
1.5 Safety Precautions
44-pin LCD power select Reserved
1.6 Jumper Settings
Watchdog timer output
DiskOnChip 2000 address setting
1.6.2 Watchdog output J2
1.6.1 Clear CMOS J1
IRQ11 interrupt
1.6.3 44-pin LCD power select J4
System reset
Chapter 1 Hardware Configuration
12 PCA-6359 Series Users Manual
1.6.4 DiskOnChip 2000 Flash disk address select J3
Page
1.7.1 Sample calculation DIMM memory capacity
1.7 System Memory
1.7.2 Supplementary information about DIMMs
1.8 Memory Installation Procedures
16 PCA-6359 Series Users Manual
CHAPTER
Connecting Peripherals
18 PCA-6359 Series Users Manual
2.1 Board Layout Connector Locations
The following table lists the connectors on the PCA-6359 Series
20 PCA-6359 Series Users Manual
2.2 Primary CN1 and Secondary CN2 IDE Connectors
2.3 Floppy Drive Connector CN3
2.4 Parallel Port Connector CN4
22 PCA-6359 Series Users Manual
Only the PCA-6359F model contains an Ultra Wide
2.5 Ultra Wide SCSI Connector CN5
2.6 USB Connector CN6
SCSI connector
10/100Base-T Ethernet connector
2.7 VGA Connector CN7
2.8 Ethernet Connector CN8
on-board VGA connector
2.9 Serial Ports CN9 COM1 CN10 COM2
26 PCA-6359 Series Users Manual
2.10 PS/2 Keyboard and Mouse Connector CN11
2.11 External Keyboard Connector CN12
2.12 IR Connector CN13
2.13.2 External speaker CN17
2.13 Front Panel Connectors CN16, CN17, CN18, CN19 and CN21
2.13.1 Keyboard lock and power on LED CN16
2.13.3 Reset CN18
If you will not be using an ATX power connector
2.14 ATX Power Control Connectors CN20 and CN21
2.13.5 ATX soft power switch CN21
Refer to the diagram on the previous page for the
2.14.2 Controlling the soft power switch
2.15 LCD Inverter Connector CN23
2.17 36-bit LCD Display Connector CN25
2.16 24-bit LCD Display Connector CN24
Chapter 2 Connecting Peripherals
2.18 Ultra SCSI Connector CN27
32 PCA-6359 Series Users Manual
Award BIOS Setup
This chapter describes how to set the card’s BIOS configuration data
CHAPTER
3.2 Entering Setup
3.1 Introduction
Figure 3-1 Setup program initial screen
checksum error....” display screen message appear
3.3 Standard CMOS Setup
3.3.1 CMOS RAM backup
If you intend to update CMOS RAM data, you have
3.4.1 Virus Warning
3.4 BIOS Features Setup
3.4.3 Boot Sequence
3.4.4 Boot Up Floppy Seek
3.4.2 CPU Internal Cache/External Cache
To disable security, select PASSWORD SETTING in
3.4.5 Boot Up NumLock Status
3.4.6 Typematic Rate Setting
3.4.8 Typematic Delay msec
3.4.13 C8000 - CFFFF Shadow/DC000-DFFFF Shadow
3.4.12 Video BIOS Shadow
3.4.10 OS Select for DRAM64 MB
3.4.11 PCI/VGA Palette Snoop
3.5.1 SDRAM CAS Lat / RAS-to-CAS
3.5 Chipset Features Setup
3.5.3 16 Bit I/O Recovery Time / 8 Bit I/O Recovery Time
3.5.2 DRAM Speculative Read
3.5.4 Memory Hole At 15M-16M
3.6 Power Management Setup
3.6.1 Power Management
3.6.2 PM Control by APM
3.6.3 Video Off Method
3.6.5 HDD Power Down
The HDD will not power down if the Power Manage
ment option is disabled
3.6.8 Soft-Off by PWR-BTTN
3.6.9 PowerOn by Ring
3.6.10 PowerOn by Alarm
string that will also cause the system to power on
3.7.1 IRQ-xx assigned to PCI/ISA PnP
3.7 PnP PCI Configuration Setup
3.8 Load BIOS Defaults
3.9 Load Setup Defaults
3.7.2 DMA-x assigned to PCI/ISA PnP
3.10.1 IDE HDD Block Mode
3.10 Integrated Peripherals
Auto
3.10.4 Onboard FDC Controller
3.10.7 UART Mode Select
3.10.8 UART2 Duplex Mode
3.10.3 On-Chip PCI IDE Primary/Secondary
If you enable the IDE HDD block mode, the en
3.11 Password Setting
3.10.11 Parallel Port Mode ECP + EPP
3.10.12 ECP Mode Use DMA
50 PCA-6359 Series Users Manual
3.13 Save & Exit Setup
3.12 IDE HDD Auto Detection
3.14 Exit Without Saving
for Windows NT Further information
PCI SVGA Setup PCA-6359V/VE/F only
Introduction Installation of SVGA driver for Windows for Windows
CHAPTER
4.1.3 Display types
4.1 Introduction
4.1.1 Chipset
4.1.2 Display memory
keyboard
4.2 Installation of SVGA Driver
4.2.1 Installation for Windows
Enter means pressing the “Enter” key on the
54 PCA-6359 Series Users Manual
4.2.2 Installation for Windows
3. In the Software License Agreement window, carefully read the Software License Agreement. If you accept all the terms of this Agreement, click on Yes
5. In the Chips and Tech. 69000 PCI Properties window, select the
Chips tab. Then click on OK
56 PCA-6359 Series Users Manual
4.2.3 Installation for Windows NT
Chapter 4 PCI SVGA Setup PCA-6359V/VE/F only
2. In the Display Type window, click on Change
58 PCA-6359 Series Users Manual
4. In the Install From Disk window, click on Browse
Chapter 4 PCI SVGA Setup PCA-6359V/VE/F only
6. In the Install From Disk window, click on OK
60 PCA-6359 Series Users Manual
9. In the Installing Driver window, click on OK
7. In the Change Display window, click on OK
8. In the Third-party Drivers window, click on Yes
Chapter 4 PCI SVGA Setup PCA-6359V/VE/F only
10. In the Display Type window, click on Close
11. In the Display Properties window, click on Close
62 PCA-6359 Series Users Manual
12. In the System Settings Change window, click on Yes
for Windows for Windows for Windows NT Further information
PCI Bus Ethernet Interface PCA-6359VE/F only
This chapter provides information on Ethernet configuration
Introduction Installation of Ethernet driver for MS-DOS and Windows
5.1 Introduction
5.2 Installation of Ethernet Driver
5.2.1 Installation for MS-DOS and Windows
ples only.You must follow the flow chart instructions
Chapter 5 PCI Bus Ethernet Interface PCA-6359VE/F only
5.2.2 Installation for Windows
66 PCA-6359 Series Users Manual
5.2.3 Installation for Windows
Chapter 5 PCI Bus Ethernet Interface PCA-6359VE/F only
3. In the Update Device Driver Wizard window, click on Next
68 PCA-6359 Series Users Manual
6. In the Browse for Folder window, click on Cancel
7. In the following Browse for Folder window, navigate to Pca6359/Lan. Highlight Lan. Then click on OK
70 PCA-6359 Series Users Manual
9. In the following Add New Hardware Wizard window, click on Next
12. In the System Settings Change window, click on Yes
11. In the Add New Hardware Wizard window, click on Finish
Chapter 5 PCI Bus Ethernet Interface PCA-6359VE/F only
5.2.4 Installation for Windows NT
2. In the Network Configuration window, click on Yes
72 PCA-6359 Series Users Manual
3. In the Network Setup Wizard window, select Wired to the network. Then click on Next
74 PCA-6359 Series Users Manual
5. In the Select Network Adapter window, click on Have Disk
Chapter 5 PCI Bus Ethernet Interface PCA-6359VE/F only
7. In the Select OEM Option window, click on OK
5.3 Further Information
support.advantech.com
76 PCA-6359 Series Users Manual
C H A P T E R
SCSI Setup and Configurations PCA-6359F only
6.1 Introduction
6.2 Before You Begin
78 PCA-6359 Series User’s Manual
Copyright 1995, 1998 Symbios Inc PCI-4.14.00
6.3 Basic Rules for SCSI Host Adapter and Device Installation
6.4 Configuring the SCSI Adapter
Symbios Inc. SDMS TM V 4.0 PCI SCSI BIOS PCI Rev. 2.0
80 PCA-6359 Series User’s Manual
6.5 SCSI Terminators
instructions to finish the installation
When you start the Windows NT installation with
either a CD-ROM boot or from the floppy disks, a
blue screen, press the F6 key. Windows NT setup
82 PCA-6359 Series User’s Manual
Programming the Watchdog Timer
84 PCA-6359 Series Users Manual
A.1 Programming the Watchdog Timer
Data
Time Interval
30 GOSUB 1000 REM Your application task #1
10 REM Watchdog timer example program
70 X=INP &H443 REM, Disable the watchdog timer
20 OUT &H443, data REM Start and restart the watchdog
86 PCA-6359 Series Users Manual
APPENDIX
Pin Assignments
low active
B.1 IDE Hard Drive Connector CN1, CN2
Table B-2 Floppy drive connector CN3
B.2 Floppy Drive Connector CN3
Table B-3 Parallel port connector CN4
B.3 Parallel Port Connector CN4
Table B-4 Ultra Wide SCSI connector CN5
B.4 Ultra Wide SCSI Connector CN5
Table B-6 VGA connector CN7
B.5 USB Connector CN6
B.6 VGA Connector CN7
Table B-5 USB1/USB2 connector CN6
1DCD 2RXD 3TXD 4DTR 5GND 6DSR 7RTS 8CTS 9RI
B.7 Ethernet 10/100Base-T RJ-45 Connector CN8
B.8 COM1/COM2 RS-232 Serial Port CN9, CN10
1XMT+ 2XMT 3RCV+ 4N/C 5N/C 6RCV 7N/C 8N/C
4 VCC
B.9 Keyboard and Mouse Connector CN11
B.10 External Keyboard Connector CN12
94 PCA-6359 Series Users Manual
Table B-12 CPU fan power connector CN14
B.11 IR Connector CN13
B.12 CPU Fan Power Connector CN14
Table B-11 IR connector CN13
Table B-14 External speaker CN17
B.13 Power LED and Keylock Connector CN16
B.14 External Speaker Connector CN17
Table B-13 Power LED and keylock connector CN16
1GND 2RESETIN
B.15 Reset Connector CN18
B.16 HDD LED Connector CN19
B.17 ATX Feature Connector CN20
Table B-18 LCD Connector CN23
B.18 LCD Connector CN23
The model number of the CN24 socket is
B.19 24-bit LCD Display Connector CN24
The model number of the CN25 socket is
B.20 36-bit LCD Display Connector CN25
Addr. range Hex Device
B.21 System I/O Ports
Table B-23 Interrupt assignments
B.22 DMA Channel Assignments
B.23 Interrupt Assignments
Table B-22 DMA channel assignments
In the PCA-6359VE/F, SCSI devices use GNT B
signals via PCI slot 2 and LAN uses GNT A via PCI
B.24 1st MB Memory Map
B.25 PCI Bus Map
104 PCA-6359 Series Users Manual
APPENDIX
DiskOnChip Installation Guide
C.1.1 DiskOnChip 2000 installation instructions
C.1 DiskOnChip 2000 Quick Installation Guide
C.1.2 Addtional information and assistance
108 PCA-6359 Series Users Manual
APPENDIX
LCD Services
D.1 LCD Services
COLOR STN
Appendix D LCD Services
Resolution
Size
PLANAR
Resolution
112 PCA-6359 Series Users Manual
Size
SHARP cont
Appendix D LCD Services
Resolution
Size
TFT cont
Resolution
114 PCA-6359 Series Users Manual
Size
