User’s Manual
PCA-6359 Series
Full-size Pentium MMX 266 PCI/ISA-bus CPU card
Copyright notice
Acknowledgements
http//support.advantech.com
Packing List
Optional Devices
PCA-6359 Series Comparison Table
Also refer to the PCA-6359 Series features elsewhere in this manual
Chapter 1 Hardware Configuration
Chapter 2 Connecting Peripherals
Contents
Chapter 3 Award BIOS Setup
Chipset Features Setup
Chapter 5 PCI Bus Ethernet Interface
Chapter 4 PCI SVGA Setup PCA-6359V/VE/F only
Chapter 6 SCSI Setup and Configurations
PCA-6359VE/F only
Appendix D LCD Services
Appendix A Programming the Watchdog Timer
Appendix C DiskOnChip 2000 Installation Guide
Appendix B Pin Assignments
Hardware Configuration
CHAPTER
Guaranteed long product supply time
1.1 Introduction
Embedded Pentium MMX CPU
1.2 Features
Chapter 1 Hardware Configuration
6. More
1.3 Specifications
Standard SBC functions
VGA function PCA-6359V/VE/F only
SCSI function PCA-6359F only
Mechanical and environmental specifications
Ethernet controller functions PCA-6359VE/F only
I/O address switchless setting Connector type RJ-45
1.4 Board Layout Main Features
Figure 1-1 PCA-6359 Series board layout dimensions
1.5 Safety Precautions
DiskOnChip 2000 address setting
1.6 Jumper Settings
Watchdog timer output
44-pin LCD power select Reserved
1.6.1 Clear CMOS J1
1.6.2 Watchdog output J2
Chapter 1 Hardware Configuration
1.6.3 44-pin LCD power select J4
System reset
IRQ11 interrupt
1.6.4 DiskOnChip 2000 Flash disk address select J3
12 PCA-6359 Series Users Manual
Page
1.7 System Memory
1.7.1 Sample calculation DIMM memory capacity
1.8 Memory Installation Procedures
1.7.2 Supplementary information about DIMMs
16 PCA-6359 Series Users Manual
Connecting Peripherals
CHAPTER
2.1 Board Layout Connector Locations
18 PCA-6359 Series Users Manual
The following table lists the connectors on the PCA-6359 Series
20 PCA-6359 Series Users Manual
2.2 Primary CN1 and Secondary CN2 IDE Connectors
2.3 Floppy Drive Connector CN3
2.4 Parallel Port Connector CN4
22 PCA-6359 Series Users Manual
SCSI connector
2.5 Ultra Wide SCSI Connector CN5
2.6 USB Connector CN6
Only the PCA-6359F model contains an Ultra Wide
on-board VGA connector
2.7 VGA Connector CN7
2.8 Ethernet Connector CN8
10/100Base-T Ethernet connector
2.9 Serial Ports CN9 COM1 CN10 COM2
2.12 IR Connector CN13
2.10 PS/2 Keyboard and Mouse Connector CN11
2.11 External Keyboard Connector CN12
26 PCA-6359 Series Users Manual
2.13.3 Reset CN18
2.13 Front Panel Connectors CN16, CN17, CN18, CN19 and CN21
2.13.1 Keyboard lock and power on LED CN16
2.13.2 External speaker CN17
Refer to the diagram on the previous page for the
2.14 ATX Power Control Connectors CN20 and CN21
2.13.5 ATX soft power switch CN21
If you will not be using an ATX power connector
2.15 LCD Inverter Connector CN23
2.14.2 Controlling the soft power switch
2.16 24-bit LCD Display Connector CN24
2.17 36-bit LCD Display Connector CN25
2.18 Ultra SCSI Connector CN27
Chapter 2 Connecting Peripherals
32 PCA-6359 Series Users Manual
Award BIOS Setup
This chapter describes how to set the card’s BIOS configuration data
CHAPTER
3.2 Entering Setup
3.1 Introduction
Figure 3-1 Setup program initial screen
If you intend to update CMOS RAM data, you have
3.3 Standard CMOS Setup
3.3.1 CMOS RAM backup
checksum error....” display screen message appear
3.4 BIOS Features Setup
3.4.1 Virus Warning
3.4.3 Boot Sequence
3.4.4 Boot Up Floppy Seek
3.4.2 CPU Internal Cache/External Cache
3.4.8 Typematic Delay msec
3.4.5 Boot Up NumLock Status
3.4.6 Typematic Rate Setting
To disable security, select PASSWORD SETTING in
3.4.11 PCI/VGA Palette Snoop
3.4.12 Video BIOS Shadow
3.4.10 OS Select for DRAM64 MB
3.4.13 C8000 - CFFFF Shadow/DC000-DFFFF Shadow
3.5 Chipset Features Setup
3.5.1 SDRAM CAS Lat / RAS-to-CAS
3.5.3 16 Bit I/O Recovery Time / 8 Bit I/O Recovery Time
3.5.2 DRAM Speculative Read
3.5.4 Memory Hole At 15M-16M
3.6 Power Management Setup
3.6.1 Power Management
3.6.2 PM Control by APM
ment option is disabled
3.6.5 HDD Power Down
The HDD will not power down if the Power Manage
3.6.3 Video Off Method
string that will also cause the system to power on
3.6.9 PowerOn by Ring
3.6.10 PowerOn by Alarm
3.6.8 Soft-Off by PWR-BTTN
3.7 PnP PCI Configuration Setup
3.7.1 IRQ-xx assigned to PCI/ISA PnP
3.8 Load BIOS Defaults
3.9 Load Setup Defaults
3.7.2 DMA-x assigned to PCI/ISA PnP
3.10.1 IDE HDD Block Mode
3.10 Integrated Peripherals
Auto
3.10.3 On-Chip PCI IDE Primary/Secondary
3.10.7 UART Mode Select
3.10.8 UART2 Duplex Mode
3.10.4 Onboard FDC Controller
3.10.12 ECP Mode Use DMA
3.11 Password Setting
3.10.11 Parallel Port Mode ECP + EPP
If you enable the IDE HDD block mode, the en
3.14 Exit Without Saving
3.13 Save & Exit Setup
3.12 IDE HDD Auto Detection
50 PCA-6359 Series Users Manual
CHAPTER
PCI SVGA Setup PCA-6359V/VE/F only
Introduction Installation of SVGA driver for Windows for Windows
for Windows NT Further information
4.1.2 Display memory
4.1 Introduction
4.1.1 Chipset
4.1.3 Display types
Enter means pressing the “Enter” key on the
4.2 Installation of SVGA Driver
4.2.1 Installation for Windows
keyboard
4.2.2 Installation for Windows
54 PCA-6359 Series Users Manual
3. In the Software License Agreement window, carefully read the Software License Agreement. If you accept all the terms of this Agreement, click on Yes
5. In the Chips and Tech. 69000 PCI Properties window, select the
Chips tab. Then click on OK
56 PCA-6359 Series Users Manual
4.2.3 Installation for Windows NT
Chapter 4 PCI SVGA Setup PCA-6359V/VE/F only
2. In the Display Type window, click on Change
4. In the Install From Disk window, click on Browse
58 PCA-6359 Series Users Manual
6. In the Install From Disk window, click on OK
Chapter 4 PCI SVGA Setup PCA-6359V/VE/F only
8. In the Third-party Drivers window, click on Yes
9. In the Installing Driver window, click on OK
7. In the Change Display window, click on OK
60 PCA-6359 Series Users Manual
Chapter 4 PCI SVGA Setup PCA-6359V/VE/F only
10. In the Display Type window, click on Close
11. In the Display Properties window, click on Close
12. In the System Settings Change window, click on Yes
62 PCA-6359 Series Users Manual
Introduction Installation of Ethernet driver for MS-DOS and Windows
PCI Bus Ethernet Interface PCA-6359VE/F only
This chapter provides information on Ethernet configuration
for Windows for Windows for Windows NT Further information
ples only.You must follow the flow chart instructions
5.2 Installation of Ethernet Driver
5.2.1 Installation for MS-DOS and Windows
5.1 Introduction
5.2.2 Installation for Windows
Chapter 5 PCI Bus Ethernet Interface PCA-6359VE/F only
5.2.3 Installation for Windows
66 PCA-6359 Series Users Manual
3. In the Update Device Driver Wizard window, click on Next
Chapter 5 PCI Bus Ethernet Interface PCA-6359VE/F only
6. In the Browse for Folder window, click on Cancel
68 PCA-6359 Series Users Manual
7. In the following Browse for Folder window, navigate to Pca6359/Lan. Highlight Lan. Then click on OK
9. In the following Add New Hardware Wizard window, click on Next
70 PCA-6359 Series Users Manual
12. In the System Settings Change window, click on Yes
11. In the Add New Hardware Wizard window, click on Finish
Chapter 5 PCI Bus Ethernet Interface PCA-6359VE/F only
5.2.4 Installation for Windows NT
2. In the Network Configuration window, click on Yes
72 PCA-6359 Series Users Manual
3. In the Network Setup Wizard window, select Wired to the network. Then click on Next
5. In the Select Network Adapter window, click on Have Disk
74 PCA-6359 Series Users Manual
7. In the Select OEM Option window, click on OK
Chapter 5 PCI Bus Ethernet Interface PCA-6359VE/F only
5.3 Further Information
support.advantech.com
76 PCA-6359 Series Users Manual
SCSI Setup and Configurations PCA-6359F only
C H A P T E R
6.1 Introduction
6.2 Before You Begin
78 PCA-6359 Series User’s Manual
Symbios Inc. SDMS TM V 4.0 PCI SCSI BIOS PCI Rev. 2.0
6.3 Basic Rules for SCSI Host Adapter and Device Installation
6.4 Configuring the SCSI Adapter
Copyright 1995, 1998 Symbios Inc PCI-4.14.00
6.5 SCSI Terminators
80 PCA-6359 Series User’s Manual
blue screen, press the F6 key. Windows NT setup
When you start the Windows NT installation with
either a CD-ROM boot or from the floppy disks, a
instructions to finish the installation
82 PCA-6359 Series User’s Manual
Programming the Watchdog Timer
Time Interval
A.1 Programming the Watchdog Timer
Data
84 PCA-6359 Series Users Manual
20 OUT &H443, data REM Start and restart the watchdog
10 REM Watchdog timer example program
70 X=INP &H443 REM, Disable the watchdog timer
30 GOSUB 1000 REM Your application task #1
86 PCA-6359 Series Users Manual
Pin Assignments
APPENDIX
B.1 IDE Hard Drive Connector CN1, CN2
low active
B.2 Floppy Drive Connector CN3
Table B-2 Floppy drive connector CN3
B.3 Parallel Port Connector CN4
Table B-3 Parallel port connector CN4
B.4 Ultra Wide SCSI Connector CN5
Table B-4 Ultra Wide SCSI connector CN5
Table B-5 USB1/USB2 connector CN6
B.5 USB Connector CN6
B.6 VGA Connector CN7
Table B-6 VGA connector CN7
1XMT+ 2XMT 3RCV+ 4N/C 5N/C 6RCV 7N/C 8N/C
B.7 Ethernet 10/100Base-T RJ-45 Connector CN8
B.8 COM1/COM2 RS-232 Serial Port CN9, CN10
1DCD 2RXD 3TXD 4DTR 5GND 6DSR 7RTS 8CTS 9RI
94 PCA-6359 Series Users Manual
B.9 Keyboard and Mouse Connector CN11
B.10 External Keyboard Connector CN12
4 VCC
Table B-11 IR connector CN13
B.11 IR Connector CN13
B.12 CPU Fan Power Connector CN14
Table B-12 CPU fan power connector CN14
Table B-13 Power LED and keylock connector CN16
B.13 Power LED and Keylock Connector CN16
B.14 External Speaker Connector CN17
Table B-14 External speaker CN17
B.17 ATX Feature Connector CN20
B.15 Reset Connector CN18
B.16 HDD LED Connector CN19
1GND 2RESETIN
B.18 LCD Connector CN23
Table B-18 LCD Connector CN23
B.19 24-bit LCD Display Connector CN24
The model number of the CN24 socket is
B.20 36-bit LCD Display Connector CN25
The model number of the CN25 socket is
B.21 System I/O Ports
Addr. range Hex Device
Table B-22 DMA channel assignments
B.22 DMA Channel Assignments
B.23 Interrupt Assignments
Table B-23 Interrupt assignments
B.25 PCI Bus Map
signals via PCI slot 2 and LAN uses GNT A via PCI
B.24 1st MB Memory Map
In the PCA-6359VE/F, SCSI devices use GNT B
104 PCA-6359 Series Users Manual
DiskOnChip Installation Guide
APPENDIX
C.1 DiskOnChip 2000 Quick Installation Guide
C.1.1 DiskOnChip 2000 installation instructions
C.1.2 Addtional information and assistance
108 PCA-6359 Series Users Manual
LCD Services
APPENDIX
D.1 LCD Services
Size
Appendix D LCD Services
Resolution
COLOR STN
Size
Resolution
112 PCA-6359 Series Users Manual
PLANAR
Size
Appendix D LCD Services
Resolution
SHARP cont
Size
Resolution
114 PCA-6359 Series Users Manual
TFT cont
