Manuals / Alto-Shaam / Kitchen Appliance / Fryer

Alto-Shaam Gas Fryer s e r v i c e c o n t r o l troubleshooting, unit troubleshooting, Problem

Models: ASF-60G Gas Fryer

1 37

Download 37 pages 18.81 Kb

Page 28

s e r v i c e

s e r v i c e

c o n t r o l troubleshooting

PROBLEM	CAUSE	SOLUTION
No power	Circuit breaker OFF	Check and reset
	Appliance not plugged in	Plug in cord
	Defective 24VAC transformer	Replace transformer
		Replace controller
No sound	Inoperable speaker	Replace controller
Button problem	Inoperable key	Replace controller
PROBE is displayed	Defective temperature probe	Replace temperature probe
	Probe not plugged in	Plug in probe
Reading wrong temperature	Defective temperature probe	Replace temperature probe.
Not heating	Defective element, relay, con-	Replace defective part
	tactor or gas valve
	Defective controller	Replace controller

unit troubleshooting

PROBLEM	CAUSE	SOLUTION
No power	Circuit breaker OFF	Check and reset
	Appliance not plugged in	Plug in cord
	Drain switch turned to the	Turn drain switch to the “closed” position
	“open” position
	Master switch turned to the	Turn master switch to the “on” position
	“off” position
Fryer will not heat	Gas valve is in the “off”	Turn gas valve to the “on” position
	position
	Gas hose is not connected	Connect gas hose
	Hi-limit is tripped	Press the hi-limit reset button located behind
		the front access door
	No oil in frypot	Add oil to frypot
Baskets will not drop	Fuse is blown on basket lift	Replace fuse
	relay board
	Interference with basket lift	Check basket lift mechanism and remove
	mechanism	interference

MN-35207 • Gas Fryer Operation & Care Manual • 26

Image 28

Alto-Shaam Gas Fryer, ASF-60G s e r v i c e c o n t r o l troubleshooting, unit troubleshooting, Problem, Cause, Solution

Contents

Installation MaintenanceOperation ASF-60GCleaning InstallationService Wire Diagramsd A N G E R W A R N I N Gd E L I V E R Y U N P A C K I N Ginstallation SAFETY PROCEdURES ANd PRECAUTIONSC A U T I O N N O T EASF - 60 Specifications installationdIMENSIONS EXTERIOR H x W x D WEIGHT ESTSITE INSTALLATION MINIMUM CLEARANCES MUSTMINIMUM CLEARANCE REqUIREMENTS DO NOT USE FORKLIFT FROM FRONT OR REAR OF UNITIMPROPER INSTALLATION MAY RESULT IN FIRE W A R N I N Ginstallation SITE INSTALLATIONdANGER v e n t i l a t i o ninstallation HEALTH OF THE OPERATOR Equipment damage and operational problemsGAS PRESSURE CHART gas specificationsNatural Gas Propane GasLEAK TESTING NEVER USE AN OPEN FLAME TO LEAK TESTinstallation gas specificationsr e s t r a i n t requirements - mobile equipment RISK OF ELECTRIC SHOCKinstallation Appliance must be secured to building structuree l e c t r i c a l requirements installationHard wired models d A N G E Roperation o i l/s h o r t e n i n g requirementsC A U T I O N W A R N I N Go p e r a t i o n start up & general operationASF-60G DO NOT touch any electrical switches Extinguish any open flamefilter key not enabled p a n e l identificationOn/Off key Temp toggle clear keyRespond to a DONE Alarm Action AlarmsHolding Timers o p e r a t i n g the controlResetting the Product Counts Display DescriptionsCheck Product Counts Exit Product CountsDisplay Descriptions continued RecipeProgramming CodePr odu c t Key programming continued o p e r a t i o nspecificoptionsoptions Note The Recipe Library contains more than 100 different choicesTemperature o p e r a t i o nPr odu c t Key programming continued SET GLOBAL TEMPERAs y s t e m programming o p e r a t i o nGRAMMING MODE exitEXITsystemSYSTEM PRO- programming modeprogramming custom product and action alarm names to the library TO CANCEL OR MODIFYto cancel or modify o p e r a t i o nSUGGESTEd FRYING TIMES operationALL SUGGESTEd FRYING TIMES ARE bASEd ON A FULL LOAd OF PROdUCT PROGRAMoperation SUGGESTEd FRYING TIMESALL SUGGESTEd FRYING TIMES ARE bASEd ON A FULL LOAd OF PROdUCT Egg Rolls froZendaily cleaning & maintenance dISCONNECT UNIT FROM POWER SOURCE bEFORE CLEANING OR SERVICINGTHOROUGHLY CLEAN DAILY c l e a n i n gboil - out procedure C A U T I O NCl e a n i n g C A U T I O Nboil - out procedure CONTROL RESETC A U T I O N c l e a n i n gs e r v i c e c o n t r o l troubleshooting unit troubleshootingPROBLEM SOLUTIONexTended limiTed frypOT warranTy s e r v i c edISCONNECT UNIT FROM POWER SOURCE bEFORE CLEANING OR SERVICING BY A QUALIFIED SERVICE TECHNICIAN AT REGULARASF-60G s e r v i c eREAR DESCRIPTIONASF-60G Kettle Assembly - 5014395 shown s e r v i c eDESCRIPTION DESCRIPTIONASF-60G 120V electrical packages s e r v i c e5014939 DESCRIPTIONs e r v i c e Lift Assembly - 5014863 shownPart numbers and drawings are subject to change without notice control panel Assembly, ASF-60G - 5013197 shown valve drain Assembly, ASF-60G - 5014881 showns e r v i c e DESCRIPTIONElectrical Assembly, 120V - ASF-60G 5014823 120V CONFIGURATIONs e r v i c e DESCRIPTIONElectrical Assembly s e r v i c eTRANSPORTATION DAMAGE and CLAIMS LIMITED WARRANTYVoltage purchased From