Manuals / Carrier / Household Appliance / Furnace

Carrier 58PHA/PHX instruction manual SEE NOTES 1,2,4,5,7,8,9 on the page, following these figures

Models: 58PHA/PHX

1 54

Download 54 pages 29.11 Kb

Page 32

Image 32

58PHA

SEE NOTES: 1,2,4,5,6,7,8,9

on the page following these figures

SEE NOTES: 1,2,4,7,8,9 on the page following these figures

A03207

A03213

Fig. 38 - Downflow Application-Vent Elbow Left then Up

Fig. 40 - Horizontal Left Application-Vent Elbow Left

	SEE NOTES: 1,2,4,5,7,8,9 on the page
SEE NOTES:1,2,3,4,5,7,8,9	following these figures
SEE NOTES:1,2,3,4,5,7,8,9
on the page following
these figures.
A03212	A03214
Fig. 39 - Downflow Application-Vent Elbow Up then Right	Fig. 41 - Horizontal Left Application-Vent Elbow Right
	then Up

Page 32

Image 32

Carrier 58PHA/PHX SEE NOTES 1,2,4,5,7,8,9 on the page, following these figures, SEE NOTES 1,2,4,5,6,7,8,9

Contents

Installation, Start---up,Operating and Service and Maintenance Instructions Series 100/A58PHA/PHX Performance Boost 80 4---WayMultipoise Induced---CombustionGas FurnaceSAFETY CONSIDERATIONS 58PHAFig. 1 - Dimensional Drawing Table 1 - Dimensions FURNACE RELIABILITY HAZARDCUT HAZARD INTRODUCTION58PHA Fig. 2 - Clearances to Combustibles CODES AND STANDARDS58PHA ELECTROSTATIC DISCHARGE ESD PRECAUTIONS PROCEDURE Fig. 3 - Return Air TemperatureGeneral Installation Gas Piping and Gas Pipe Pressure TestingLOCATION 58PHAFig. 4 - Multipoise Orientations GENERALFig. 5 - Installation in a Garage 58PHAELECTRICAL OPERATION HAZARD PERSONAL INJURY AND/OR PROPERTY DAMAGE HAZARDAIR FOR COMBUSTION AND VENTILATION Fig. 6 - Prohibit Installation on Back58PHA FIRE HAZARDVolume Volume21ft3 1000 Btu/hrINSTALLATION UPFLOW INSTALLATION58PHA or sealed andDOWNFLOW INSTALLATION Fig. 11 - Floor and Plenum Opening Dimensions58PHA Fig. 10 - Leveling LegsFig. 13 - Furnace, Plenum, and Coil Assembly or Coil Box Installed on a Combustible FloorFURNACE APPROVED COIL ASSEMBLY OR COIL BOX 58PHATable 4 - Opening Dimensions - In. mm HORIZONTAL INSTALLATION58PHA Suspended Furnace Support58PHA Side Return Air InletFILTER ARRANGEMENT CARBON MONOXIDE AND POISONING HAZARDUPFLOWDOWNFLOW HORIZONTAL 58PHAFig. 14 - Duct Flanges Fig. 15 - Horizontal Unit SuspensionFig. 16 - Horizontal Suspension with Straps Fig. 17 - Typical Attic Installation58PHA 58PHA Return Air ConnectionsFIRE HAZARD GAS PIPINGTable 6 - Maximum Capacity of Pipe 58PHATable 5 - Air Delivery - CFM With Filter A02163 58PHAA02075 58PHA Fig. 21 - Burner and Manifold2” 51mm Street Elbow A0216258PHA Table 7 - Electrical DataFig. 22 - Typical Gas Pipe Arrangement ELECTRICAL CONNECTIONS115-VWIRING 58PHAFURNACE MAY NOT OPERATE FIRE HAZARDPOWER CORD INSTALLATION IN FURNACE J-BOX BX CABLE INSTALLATION IN FURNACE J-BOX24-VWIRING ACCESSORIES58PHA Fig. 24 - Furnace Control58PHA CARBON MONOXIDE POISONING HAZARDGENERAL VENTING REQUIREMENTS MASONRY CHIMNEY REQUIREMENTS58PHA ditionertioner Pump Dual FuelNOTES FOR FIGURES 58PHAand Single-SpeedHeat Pump and Two-SpeedHeat PumpInstallations with Type-BDouble Wall Vent Connectors NFPA & AGA58PHA Exterior Masonry Chimney FAN + NATCHIMNEY INSPECTION CHART 58PHA58PHA ADDITIONAL VENTING REQUIREMENTSCUT HAZARD BURN HAZARD58PHA Fig. 34 - Upflow Application-VentElbow UpFig. 35 - Upflow Application-VentElbow Right Fig. 37 - Downflow Application-VentElbow UpSEE NOTES 1,2,4,5,7,8,9 on the page following these figures58PHA SEE NOTES 1,2,4,5,6,7,8,9then Up 58PHASEE NOTES 1,2,4,5,7,8,9 Venting Notes for Figures Fig. 47 - Using Tin Snips to Cut Tie Points58PHA 58PHA Fig. 48 - Rounded End of KnockoutFig. 49 - Knockout Pulled Loose Fig. 51 - Remove Knockout with HammerSTART-UP,ADJUSTMENT, AND SAFETY CHECK Start-UpProceduresAdjustments 58PHA58PHA In Canadafollow exclusively the National Fuel Gas Code Table 10 - Altitude Derate Multiplier for U.S.A58PHA ELECTRICAL SHOCK HAZARDFig. 52 - Gas Control Valve Fig. 53 - Orifice HoleCheck Safety Controls 58PHATable 11 - Speed Selection FURNACE OVERHEATING HAZARDChecklist 1.Put away tools and instruments. Clean up debris58PHA Table 12 - Gas Rate Cu Ft./Hr58PHA A0822058PHA A08220ASERVICE AND MAINTENANCE PROCEDURES ELECTRICAL CONTROLS AND WIRINGINTRODUCTION 58PHA58PHA A08221SERVICE Fig. 55 - Service Label58PHA STATUSCARE AND MAINTENANCE CLEANING AND/OR REPLACING AIR FILTER58PHA FIRE OR EXPLOSION HAZARDCLEANING HEAT EXCHANGER 58PHAUNIT DAMAGE HAZARD ELECTRICAL SHOCK HAZARDFig. 57 - Igniter Position-TopView 58PHAFig. 56 - Igniter Position-SideView Fig. 58 - Cleaning Heat Exchanger Cell 58PHAFIRE OR EXPLOSION HAZARD Sequence of Operation58PHA 2.Cooling Modeb.Two-SpeedCooling 3.Thermidistat ModeWiring Diagrams Troubleshooting58PHA 5.Heat pumpA08176 Fig. 59 - Wiring Diagram58PHA START Fig. 60 - Troubleshooting Guide58PHA Adapter Kit 58PHACatalog No 58PHA---03SI

SEE NOTES: 1,2,4,5,6,7,8,9

SEE NOTES: 1,2,4,5,7,8,9 on the page

following these figures