Model 2000 Series
Door-type High Temperature Dishwasher
Manual P/N 114614 rev. J
2000 Series
Parts Distributor Tel
National Service Department
Model Number Serial Number VoltageHertz Phase Service Agent Tel
In Canada
In Canada
In the U.S.A
REGISTER YOUR PRODUCT ONLINE
Model
FAILURE TO REGISTER YOUR PRODUCT MAY VOID YOUR WARRANTY
PRODUCT REGISTRATION CARD
Serial #
Revision History
Revision History
LIMITED WARRANTY
Limited Warranty
Table of Contents
Table of Contents
2000 Series Door-type Dishwasher
2000 Series
Model Description
Model Description
Optional Equipment consult factory
Installation Receiving
1. Inspect the outside of the dishwasher carton for signs of damage
Installation
Converting Straight-through Operation to Corner Operation
Converting Straight-through Operation to Corner Operation
wall
Installation
1-phase field conversion instructions
Three Phase Operation
Refer to the next page for 3-phase to
Electrical Connections
Rewire Wash Tank Heater Element for 1PH
Field Conversion from 3-phase to 1-phase Operation
Install Main Terminal Block Jumper Wire
Rewire Booster Heater Element for 1PH
Drain Connection
Hot Water Connection
Installation
4. DO NOT REMOVE THE JUMPER BETWEEN THE COMMON TERMINALS
Vent Fan Control
Chemical Dispenser Provisions
Installation
Initial Start-up
Installation Check List
is set between 20-25 PSI
Normal Operation Mode
Operation
Final Rinse Pressure
Normal Operation Mode continued
20-25 PSI
150F/66C
DO NOT REMOVE WARES UNTIL THE FINAL RINSE CYCLE HAS
Rinse Sentry Operation Mode
Automatic Drain Cycle
SANITIZED THE WARES AND THE GREEN CYCLE LIGHT GOES OUT
Cleaning and Maintenance
Cleaning
After Each Meal Period or every 8 Hours of Operation
Rinse Arm Spindle
Paper Clip
Plug
Wash Spray arm
Danger
De-liming
Cleaning and Maintenance
Weekly Maintenance
Maintenance
Daily Maintenance
Cleaning and Maintenance
Condition
Solution
Troubleshooting
Cause
Illustrations
Service Replacement Parts
Service Replacement Parts
Page
Wash Pump/Motor Assembly
Description
Part
Wash Pump/Motor Assembly
Booster Assembly
Description
Booster Assembly
Part
JUMPER, STRIP spares used for conversion
Control Panel Assembly
Part
Control Panel Assembly
Description
3324
2815
Wash and Rinse Spray Arm Assemblies
Description
Part
Wash and Rinse Spray Arm Assemblies
Hood and Door Assembly
Part
Hood and Door Assembly
Description
Track Assemby
Part
Track Assembly
Description
Wash Tank Heat, Drain, Screens, Hoses
Description
Wash Tank Heat, Drain, Screens, Hoses
Part
JUMPER, STRIP spare for conversrion
Part
Dish Racks, Line Strainer, PRV
Description
Description
Part
Dish Racks, Line Strainer, PRV
Electrical Schematic
Timer Chart, Electrical Schematic
Timer Chart
Electrical Schematic, Timer Chart
WASH
Timer Chart
TIME CYCLE - DH/MD2000
RINSE
702119
1 & 3 PHASE
Electrical
AT! TENTION - VERY IMPORTANT