Contents
Manual P/N 114614 rev. J
Door-type High Temperature Dishwasher
Model 2000 Series
2000 Series
Model Number Serial Number VoltageHertz Phase Service Agent Tel
National Service Department
Parts Distributor Tel
In Canada
REGISTER YOUR PRODUCT ONLINE
In the U.S.A
In Canada
PRODUCT REGISTRATION CARD
FAILURE TO REGISTER YOUR PRODUCT MAY VOID YOUR WARRANTY
Model
Serial #
Revision History
Revision History
Limited Warranty
LIMITED WARRANTY
2000 Series Door-type Dishwasher
Table of Contents
Table of Contents
Model Description
Model Description
2000 Series
Optional Equipment consult factory
1. Inspect the outside of the dishwasher carton for signs of damage
Installation Receiving
Converting Straight-through Operation to Corner Operation
Installation
Installation
wall
Converting Straight-through Operation to Corner Operation
Refer to the next page for 3-phase to
Three Phase Operation
1-phase field conversion instructions
Electrical Connections
Install Main Terminal Block Jumper Wire
Field Conversion from 3-phase to 1-phase Operation
Rewire Wash Tank Heater Element for 1PH
Rewire Booster Heater Element for 1PH
Installation
Hot Water Connection
Drain Connection
Chemical Dispenser Provisions
Vent Fan Control
4. DO NOT REMOVE THE JUMPER BETWEEN THE COMMON TERMINALS
Installation
is set between 20-25 PSI
Installation Check List
Initial Start-up
Operation
Normal Operation Mode
20-25 PSI
Normal Operation Mode continued
Final Rinse Pressure
150F/66C
Automatic Drain Cycle
Rinse Sentry Operation Mode
DO NOT REMOVE WARES UNTIL THE FINAL RINSE CYCLE HAS
SANITIZED THE WARES AND THE GREEN CYCLE LIGHT GOES OUT
After Each Meal Period or every 8 Hours of Operation
Cleaning
Cleaning and Maintenance
Plug
Paper Clip
Rinse Arm Spindle
Wash Spray arm
Cleaning and Maintenance
De-liming
Danger
Daily Maintenance
Maintenance
Weekly Maintenance
Cleaning and Maintenance
Troubleshooting
Solution
Condition
Cause
Service Replacement Parts
Service Replacement Parts
Illustrations
Page
Wash Pump/Motor Assembly
Wash Pump/Motor Assembly
Part
Description
Booster Assembly
Part
Booster Assembly
Description
JUMPER, STRIP spares used for conversion
Control Panel Assembly
Description
Control Panel Assembly
Part
Wash and Rinse Spray Arm Assemblies
2815
3324
Wash and Rinse Spray Arm Assemblies
Part
Description
Hood and Door Assembly
Description
Hood and Door Assembly
Part
Track Assemby
Description
Track Assembly
Part
Wash Tank Heat, Drain, Screens, Hoses
Part
Wash Tank Heat, Drain, Screens, Hoses
Description
JUMPER, STRIP spare for conversrion
Description
Dish Racks, Line Strainer, PRV
Part
Dish Racks, Line Strainer, PRV
Part
Description
Timer Chart
Timer Chart, Electrical Schematic
Electrical Schematic
Electrical Schematic, Timer Chart
TIME CYCLE - DH/MD2000
Timer Chart
WASH
RINSE
Electrical
1 & 3 PHASE
702119
AT! TENTION - VERY IMPORTANT